Auto Parts Search
1999 Pontiac Grand Prix CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 1999 Pontiac Grand Prix 3.1 V6 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
Hydraulic Brake Systems -> General Motors -> Diagnosis & Testing
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
Refer to...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Component Locations -> Malibu (1997-03), Monte Carlo, Impala, Alero, Cutlass (1997-99) & Grand Am (1999-05) & Grand Prix
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
- Raise and suitably support vehicle.
- Remove wheel and tire.
- Remove stabilizer shaft link.
- Remove front wheel drive shaft nut. Insert a drift or a flat-bladed tool into caliper and rotor to prevent rotor from turning.
- Disconnect outer tie rod assembly from steering knuckle.
- Separate ball joint from steering knuckle. Do not attempt to move vehicle with drive axle(s) removed from wheel bearing. Wheel(s) could fall off, dropping vehicle to ground and causing personal injury or damage to vehicle.
- Separate front wheel drive axle from front wheel drive shaft bearing using a suitable pu...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
Alternator, Replace
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
- Disconnect battery ground cable.
- Remove serpentine drive belt tension by rotating drive belt tensioner counterclockwise using a suitable breaker bar.
- Remo...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
General Motors Corp./Saturn Cars -> Check Engine Or Service Now Soon Engine Indicator Lamps (Gasoline Engines w/Electronic Engine Controls Or EFI) -> Except LeMans, Metro, Prizm, Storm & Vibe
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
The Check Engine lamp should light when the ignition is turned On. When the engine is started, the lamp should go off. If the lamp remains on for 10 seconds or constantly after the engine is started, the self diagnosis system has detected a fault condition and has stored a code in the system Electronic Control Module (ECM) or Powertrain Control Module (PCM). After diagnosis and repair, the ECM memory can be cleared of codes as follows:
On models except Cadillac with DEFI, remove the ECM/PCM fuse or disconnect the battery ground cable for approximately 30...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
Lower
- Disconnect negative battery cable.
- Drain cooling system into a suitable container.
- Reposition hose clamp from water pump.
- Remove radiator outlet hose from water pump.
- Remove lower radiator air deflector.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator and vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1999 Pontiac Grand Prix AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1999 Pontiac Grand Prix 3.8 V6 GAS
- Rotate tensioner counterclockwise to remove the dri...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1999 Pontiac Grand Prix AUTOMOBILES
Component location diagrams for most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S. from 1990+.
Instrument Panel Components Diagram for 1999 Pontiac Grand Prix 3.8 V6 GAS Components on diagram: |
Retained Power Accessory Components Diagram for 1999 Pontiac Grand Prix 3.8 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1999 Pontiac Grand Prix AUTOMOBILES
OEM drawn wiring diagrams for most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S.
1999 Pontiac Grand Prix 3.1 V6 GAS Wiring Diagram Components on diagram: |
1999 Pontiac Grand Prix 3.8 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1999 Pontiac Grand Prix AUTOMOBILES
OEM TSB listings for most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 1999 Pontiac Grand Prix 3.1 V6 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 1999 Pontiac Grand Prix 3.1 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1999 Pontiac Grand Prix AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1999 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand Prix SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1999 Pontiac Grand Prix vehicle. |
Access the Complete guide! |