Auto Parts Search
2003 Pontiac Grand AM CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
Hydraulic Brake Systems -> General Motors -> Brake System Bleed -> Bleed Sequence -> Hydraulic System Flush -> Manual -> Pressure
Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS
Manual
Pressure bleeding is recommended for all hydraulic systems. However, if a pressure bleeder is unavailable, use the following procedure. Brake fluid damages painted surfaces. Immediately clean any spilled fluid.
- Remove vacuum reserve by pumping brakes several times with engine off.
- Fill master cylinder reservoir with clean brake fluid. Do not let reservoir fall below half full during bleeding procedure.
- If required, bleed master cylinder as follows:
- Loosen master cylinder forward brake line connection until fluid flows from reservoir, then tighten brake line.
- Have assistant t...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Replacement -> Except Aveo, Chevette 1.8L Diesel, Corvette, GTO, LaCrosse, Malibu (2004-06) & Malibu Maxx, Vibe, XLR, 2004-05 Corvette & 1998-2002 Metro & Prizm
Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the v...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS
- Raise and suitably support vehicle.
- Remove wheel and tire.
- Remove stabilizer shaft link.
- Remove front wheel drive shaft nut. Insert a drift or a flat-bladed tool into caliper and rotor to prevent rotor from turning.
- Disconnect outer tie rod assembly from steering knuckle.
- Separate ball joint from steering knuckle. Caution: Do not attempt to move vehicle with drive axle(s) removed from wheel bearing. Wheel(s) could fall off, dropping vehicle to ground and causing personal injury or damage to vehicle.
- Separate front wheel drive axle from front wheel drive shaft bearing using a su...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
Starter, Replace
Vehicle: 2003 Pontiac Grand AM 2.2 L4 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove mounting bolts and lower starter.
- Disconnect starter e...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
General Motors Corp./Saturn Cars -> Low Coolant Lamp ->
Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS
This lamp should light when engine coolant level in the radiator drops below a predetermined le...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2003 Pontiac Grand AM 2.2 L4 GAS
Lower
- Disconnect negative battery cable.
- Drain cooling system into a suitable container.
- Reposition outlet hose clamp from cylinder head.
- Remove outlet hose from cylinder head.
- Raise and support vehicle.
- Reposition hose clamp from surge tank pipe.
- Remove radiator outlet hose from surge tank pipe.
- Reposition hose clamp from radiator.
- Remove radia...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2003 Pontiac Grand AM AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2003 Pontiac Grand AM 2.2 L4 GAS
- Raise and support vehicle .
- Remove front fender liner.
- R...
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2003 Pontiac Grand AM AUTOMOBILES
Component location diagrams for most 2003 Pontiac Grand AM cars and light trucks sold in the U.S. from 1990+.
Below Left Side of I/P, Near The Steering Column Diagram for 2003 Pontiac Grand AM 3.4 V6 GAS Components on diagram: |
Sunroof Assembly Diagram for 2003 Pontiac Grand AM 3.4 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2003 Pontiac Grand AM AUTOMOBILES
OEM drawn wiring diagrams for most 2003 Pontiac Grand AM cars and light trucks sold in the U.S.
2003 Pontiac Grand AM 3.4 V6 GAS Wiring Diagram Components on diagram: |
2003 Pontiac Grand AM 2.2 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2003 Pontiac Grand AM AUTOMOBILES
OEM TSB listings for most 2003 Pontiac Grand AM cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2003 Pontiac Grand AM 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2003 Pontiac Grand AM AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2003 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2003 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2003 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2003 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2003 Pontiac Grand AM SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2003 Pontiac Grand AM vehicle. |
Access the Complete guide! |