Auto Parts Search
2006 Audi A4 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Audi REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2006 Audi A4 car and truck
repair procedures including Audi engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Audi A4 automobile. Try the Automotix DIY solution today!
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Audi -> Fuel Filter Replacement -> Gasoline Engines -> Removal & Installation
Vehicle: 2006 Audi A4 2.0 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Obtain the vehicle owner's radio theft protection code, then disconnect the battery ground cable. Briefly open fuel filler cap to relieve system pressure, then close it again.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while it relearns its adaptive strategy.
Removal & Installation
On A4 and S4 mod...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2006 Audi A4 2.0 L4 GAS
- Remove wheel trim. Pull trim cap off light-alloy wheels, using puller in vehicle tool kit.
- Loosen bolt for drive axle outer joint by a maximum of 90°. Vehicle must be standing on its wheels to avoid risk of accident.
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Screw all five wheel bolts hand-tight.
- Remove hex bolt for drive axle outer joint.
- Unbolt drive axle from flange shaft on transmission. If not enough space is av...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Component Replacement -> Installation -> Metal Valve Body & Wheel Electronics -> Removal -> TPMS Control Module -> TPMS Rear Antenna
Vehicle: 2006 Audi A4 Cabriolet 1.8 L4 GAS
Metal Valve Body & Wheel Electronics
Removal
The nickel plated valve insert must be replaced every tire change. Release air from the tire by removing the nickel plated valve insert. The TPMS sensor can be reused, but a damaged sensor must be replaced.
- Loosen the wheel lug nuts.
- Raise and support the vehicle with jack stands.
- Remove the wheel and tire assembly.
- When dismounting the tire from the rim, note the following:
- When using pressure paddles, remove the side of the tire opposite the valve stem from the rim first. Do not use the paddles in area (a) , Fig. .
- Position the tire c...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Alternator, Replace
Vehicle: 2006 Audi A4 3.2 V6 GAS
- Disconnect battery ground cable.
- Remove engine front cover.
- Remove inlet air guide screws and guides.
- Raise and support vehicle.
- Release fasteners and remove front noise insulation.
- Remove front bumper cover.
- Bring lock carrier into service position:
- Remove intake air duct between lock carrier and air cleaner housing at lock carrier.
- Screw in suitable guide bolts into threaded holes.
- Remove lock carrier mounting bolts, then pull lock carrier toward front of vehicle.
- Secure lock carrier with guide bolts.
- Remove left and right engine covers.
- Remove combination light mounting bolts.
- Pull lo...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Cabin Air Filter Service -> Audi -> 1996-2008 A4, 1998 Cabriolet, 2002-08 S4 & 2007-09 RS4
Vehicle: 2006 Audi A4 2.0 L4 GAS
On 1996-2003 models, the cabin air filter should be replaced every 20,000 miles.
On 2004-09 models, the cabin air filter should be replaced at 15,000 miles, then every 20,000 miles.
- Open the hood.
- Remove the righthand side air intake pl...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Audi -> Tire Pressure Monitor System (TPMS) Warning Indicator -> 2005-09 A4, RS4 & S4 -> Relearn Procedure -> Reset Procedure
Vehicle: 2006 Audi A4 2.0 L4 GAS
Reset Procedure
- Check and the adjust tire pressure to the manufacturer's specifications.
- Press the Reset button located on the windshield wiper control lever until DISPLAY TYPE appears on the instrument cluster.
- Press button on end of the windshield wiper control lever to select SET option.
- Press the Reset button on the windshield wiper control lever.
- Press button on end of the windshield wiper control lever to select TIRE PRESSURE option.
- Press the Reset button on the windshield wiper control lever.
- Press button on end of the windshield wiper control lever to select STORE PRESSUR...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2006 Audi A4 2.0 L4 GAS
Inlet
- Drain coolant into a suitable container.
- Reposition hose clamp at heater core and remove hose.
- Reposition hose clamp at cylinder head and remove hose.
- Remove hose from vehicle.
- Reverse procedure to instal...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Audi A4 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Audi A4 3.2 V6 GAS
- Remove front engine cover.
- Remove air duct and mounting bolts.
- Raise and support vehicle.
- Loosen quick-release fasteners and remove front noise insulation. Rear section of noise insulation remains installed.
- Mark direct...
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Audi A4 AUTOMOBILES
Component location diagrams for most 2006 Audi A4 cars and light trucks sold in the U.S. from 1990+.
 Sensor for Parking Diagram for 2006 Audi A4 2.0 L4 GASComponents on diagram: |
 Console Diagram for 2006 Audi A4 Cabriolet 1.8 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Audi A4 AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Audi A4 cars and light trucks sold in the U.S.
 2006 Audi A4 3.2 V6 GAS Wiring DiagramComponents on diagram: |
 2006 Audi A4 2.0 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Audi A4 AUTOMOBILES
OEM TSB listings for most 2006 Audi A4 cars and light trucks sold in the U.S. from 1985+.
|
Document: AIRBAG / PYROTECHNIC SAFETY BELT DEPLOYMENT INQUIRIES - REVISED Vehicle: 2006 Audi A4 3.2 V6 GAS Auto Systems: |
|
Document: AUDI TIRE PRESSURE MONITORING SYSTEMS OVERVIEW - REVISED Vehicle: 2006 Audi A4 3.2 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Audi A4 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Audi A4 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Audi A4 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Audi A4 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Audi A4 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Audi A4 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2006 Audi A4 vehicle.
|
| Access the Complete guide! |
