Auto Parts Search
2009 Audi A6 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Audi REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Audi A6 3.2 V6 GAS
- On models with air spring suspension, position vehicle on lifting platform.
- On models without air spring suspension, raise and support vehicle.
- On all models, remove wheel.
- Loosen collar bolt for outer joint of drive axle.
- Remove noise insulation.
- Remove drive axle from transmission flange shaft.
- Remove drive axle. If there is not sufficient room to remove drive axle, proceed as follo...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
Wiring Diagrams -> Wire Color Code Identification -> Wiring Diagram Legend
Vehicle: 2009 Audi A6 3.2 V6 GAS
Refer to Fig. for wiring diagrams.
...
[[table data]] [[table data]]CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Audi A6 3.2 V6 GAS
- Disconnect battery ground cable at battery.
- Remove front noise insulation.
- Remove bolt and nut, then remove right lock carrier brace.
- Pivot drive belt tensioner clockwise and remove belt from alternator pulley.
- On models with automatic transmission, remove bolt on transmission oil line bracket.
- On all models, loosen nut on electrical wiring bracket several turns.
- Drain coolant into a suitable container.
- Remove upper coolant hose fro...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
Cabin Air Filter Service -> Audi -> 2005-09 A6, 2007-09 S6, 2008-09 R8 & 2009 RS6
Vehicle: 2009 Audi A6 3.2 V6 GAS
The cabin air filter should be replaced at 15,000 miles, then every 20,000 miles.
- Remove the instrument panel trim from under the glove compartment, Fig. .
- From under the right side of the instrument panel, release the cabin air filter cover retainer and remove the cover, Fig.
- Remove the first cabin filter element f...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
Audi -> Auto-Check Indicator System ->
Vehicle: 2009 Audi A6 3.2 V6 GAS
The auto-check system will monitor certain vehicle systems when the ignition switch is placed in the On position and vehicle is operated. When all monitored systems are functioning properly, the system display will indicate "OK" for a few seconds after the ignition switch is placed in the On position.
This system monitors brake fluid level and hydraulic pressure, engine oil pressure, coolant temperature and level, brake pad wear, headlamps and tail lamps, battery voltage, washer fluid level and fuel level.
When the auto-check yellow or r...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
Radiator, Replace
Vehicle: 2009 Audi A6 3.2 V6 GAS
- Open cap of coolant expansion tank.
- Remove noise insulation and mountings where present.
- Remove left and right front wheel housing liners.
- Remove front bumper cover.
- Drain coolant into a suitable container.
- Disconnect upper coolant hose at radiator.
- Disconnect lower coolant hose from radiator.
- Remove bolts securing air duct.
- Remove air duct.
- On models with automatic transmission, disconnect ATF-lines at top and bottom of radiator, catch dripping oil in a suitable container. Tie ATF lines up to longitudinal member to prevent fluid from escaping.
- On all models, remove bolts and remove air...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Audi A6 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Audi A6 3.2 V6 GAS
- Remove front engine cover.
- Mark direction of rotation of drive belt with chalk or felt pen, if belt is to be reused.
- Rotate driv...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Audi A6 AUTOMOBILES
OEM TSB listings for most 2009 Audi A6 cars and light trucks sold in the U.S. from 1985+.
Document: AIRBAG / PYROTECHNIC SAFETY BELT DEPLOYMENT INQUIRIES - REVISED Vehicle: 2009 Audi A6 3.2 V6 GAS Auto Systems: |
Document: AUDI TIRE PRESSURE MONITORING SYSTEMS OVERVIEW - REVISED Vehicle: 2009 Audi A6 3.2 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Audi A6 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Audi A6 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Audi A6 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Audi A6 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Audi A6 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Audi A6 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Audi A6 vehicle. |
Access the Complete guide! |