Auto Parts Search
We have info for following modifications of 1993 Chevrolet Corsica
- 1993 Chevrolet Corsica LT 2.2 L4 GAS, CID:134, Fuel Injection, Aspiration:134, Engine VIN:, Desg:4
- 1993 Chevrolet Corsica LT 3.1 V6 GAS, CID:189, Fuel Injection, Aspiration:189, Engine VIN:, Desg:T
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Corsica AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 Chevrolet Corsica cars and light trucks from 1990+.
Power Brake Units -> Power Brake Unit Service -> AC-DELCO TANDEM DIAPHRAGM TYPE -> Assemble -> Assembly -> BCIA SINGLE DIAPHRAGM TYPE -> BCIA TANDEM DIAPHRAGM TYPE -> Disassemble -> Disassembly -> GEO METRO SINGLE DIAPHRAGM TYPE -> OVERHAUL -> TOYOTA/GM SINGLE DIAPHRAGM TYPE
Vehicle: 1993 Chevrolet Corsica LT 3.1 V6 GAS
AC-DELCO TANDEM DIAPHRAGM TYPE
OVERHAUL
Disassemble
- Remove pedal pushrod boot, silencer, check valve, vacuum switch and grommets, as equipped, then the front housing seal.
- Scribe matching marks between front and rear housing sections, then mount booster assembly in suitable holding fixture with rear housing facing up.
- Apply pressure to housing with holding fixture forcing screw and rotate rear housing counterclockwise to unlock housing halves.
- Slowly release spring tension, then remove booster assembly from holding fixture. Do not allow spring tension to release suddenly, as ...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Corsica BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Corsica AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 Chevrolet Corsica cars and light trucks from 1990+.
Disc Brakes -> AC-Delco Single Piston Front Disc Brake (Type 2) -> Troubleshooting -> BRAKE ROUGHNESS
Vehicle: 1993 Chevrolet Corsica LT 3.1 V6 GAS
BRAKE ROUGHNESS
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pulsation is experienced at low speeds, the disc may have excessive thickness variation. To check for this condition, measure the disc at 12 points with a micrometer at a radius approximately one inch from edge of disc. If thic...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Corsica BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Corsica AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 Chevrolet Corsica cars and light trucks from 1990+.
Power Brake Units -> Description -> AC-DELCO SINGLE DIAPHRAGM TYPE -> AC-DELCO TANDEM DIAPHRAGM TYPE -> BCIA SINGLE & TANDEM DIAPHRAGM TYPE
Vehicle: 1993 Chevrolet Corsica LT 3.1 V6 GAS
AC-DELCO TANDEM DIAPHRAGM TYPE
This unit utilizes a vacuum power chamber, consisting of a front and rear shell, housing divider, front and rear diaphragm, plate assemblies, hydraulic pushrod and a diaphragm return spring, Figs. and .
The unit operates in much the same manner as the single diaphragm unit described previously. The diaphragm and plate assemblies utilize the pressure differential between the engine intake manifold vacuum and atmospheric pressure to assist in braking.
AC-DELCO SINGLE DIAPHRAGM TYPE
The AC-Delco power booster assembly, Fig. is located along the bulkhead in ...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Corsica BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Corsica AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 Chevrolet Corsica cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Service -> Assemble -> CORVETTE -> Disassemble -> EXCEPT CORVETTE -> MASTER CYLINDER OVERHAUL -> WHEEL CYLINDER OVERHAUL
Vehicle: 1993 Chevrolet Corsica LT 2.2 L4 GAS
MASTER CYLINDER OVERHAUL
EXCEPT CORVETTE
Disassemble
Refer to Figs. and when performing the following procedures.
- Remove master cylinder from vehicle as follows:
- Disconnect and plug hydraulic lines.
- Remove two master cylinder attaching nuts, then the master cylinder.
- Remove reservoir cover and diaphragm. Discard old brake fluid in reservoir.
- Inspect cover and diaphragm. Replace if cut, cracked or deformed.
- Remove fluid level switch, if equipped.
- On models with compact master cylinder, remove proportioner valve assembly, Fig. .
- Depress primary piston and remove lock ring.
- Plug primary fl...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Corsica BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Corsica AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 Chevrolet Corsica cars and light trucks from 1990+.
Power Brake Units -> Adjustments -> AC-Delco Type -> AIR METHOD -> BRAKE PEDAL -> GAUGE METHOD -> PUSHROD -> Single Diaphragm Type -> Toyota/GM Single Diaphragm Type
Vehicle: 1993 Chevrolet Corsica LT 3.1 V6 GAS
BRAKE PEDAL
Toyota/GM Single Diaphragm Type
- With engine running and brake pedal in rest position, measure distance between face of pedal and floor mat.
- If distance is not 5.79-6.18 inches, adjust pedal height as follows:
- Remove left lower instrument panel trim section and air duct.
- Loosen stop lamp switch sufficiently to gain clearance for pedal adjustment.
- Loosen locknut and rotate pedal pushrod as needed to obtain specified pedal height, then tighten locknut.
- Adjust position of brake light switch so that plunger lightly contacts pedal stopper and brake lamps are off when pedal is release...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Corsica BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Corsica AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 Chevrolet Corsica cars and light trucks from 1990+.
Disc Brakes -> AC-Delco Single Piston Front Disc Brake (Type 2) -> Description
Vehicle: 1993 Chevrolet Corsica LT 2.2 L4 GAS
The caliper has a single piston and is mounted to the support bracket by two mounting bolts, Figs. through . The caliper assembly slides on the two mounting bolts. Upon brake application, fluid pressure against the piston forces the inboard s...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Corsica BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1993 Chevrolet Corsica vehicle. |
Access the Complete guide! |