Auto Parts Search
1999 Chevrolet Tahoe CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
Component Replacement & Adjustment -> Light Duty Trucks & Vans -> Dash Panel, Replace -> Montana, Silhouette, Trans Sport & Venture -> S & T Series -> Tracker
Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS
S & T Series
- Remove instrument cluster trim screws, then the trim.
- Tilt steering column down, then set parking brake and lock wheels.
- On models equipped with automatic transmission, place transmission in Low.
- On all models, remove lefthand dash panel sound insulator, Fig. .
- Disconnect Data Link Connector (DLC), then remove RKE/delay module.
- Remove center dash panel sound insulator, Fig. .
- Remove parking brake release cable by squeezing retainers, then disconnect cable slug from park brake mechanism.
- Remove knee bolster, then t...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
Anti-lock Brakes -> Kelsey-Hayes -> System Service -> 1997-2000 C & K Series Except 1999-2000 Sierra, Silverado & 2000 Suburban, Tahoe & Yukon -> 1997-2000 w/310 ABS -> 1999-2000 Sierra, Silverado & 2000 Suburban, Tahoe, Yukon & 2001 C & K Series -> 2000-01 w/325 ABS -> Astro & Safari -> Brake Pressure Modulator Valve (BPMV) -> Brake System Bleed -> C & K Series Except C3500HD -> C3500HD -> Component Replacement -> Electronic Brake Control Module (EBCM) -> Front Wheel Speed Sensor -> G Van -> Installation -> Manual Bleed -> P Series -> Pressure Bleed -> Removal -> S & T Series
Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS
Brake System Bleed
Gravity and vacuum bleeding procedures are not recommended for use with the anti-lock brake system. The manual bleed procedure is the preferred method, although pressure bleeding is also possible. Do not pump the brake pedal during the bleeding process, as fluid aeration may occur.
Manual Bleed
- Raise and support vehicle, then connect a clear plastic tube to brake bleed screw at righthand rear wheel.
- Place free end of tube in a glass jar partially filled with clean brake fluid. Ensure end of tube remains submerged in fluid and master cylinder reservoir is kept full.
- ...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Except Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Tracker & Uplander -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Engines Less Fuel Pressure ...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Remove drive axle center cap, if equipped.
- Insert a drift or large screwdriver through brake caliper into one of the brake rotor vanes in order to prevent drive axle wheel drive shaft from turning.
- Remove nut and washer from hub. Do not reuse nut. A new nut must be used when installing wheel drive shaft.
- Using axle remover tool No. J 45859 or equivalent, press wheel drive shaft from hub.
- Remove bolts securing wheel dr...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
Starter, Replace
Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect starter battery positive cable and wiring harness.
- Remove starter motor mounting bolts, then washers with shims, if required.
- Remove starter...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
General Motors Corp./Saturn Trucks -> Change Trans Fluid Indicator ->
Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS
This message will appear on the DIC (Driver Information Center) when it is time to change the transmission fluid....
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 1999 Chevrolet Tahoe 6.5 V8 DIESEL
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from water pump.
- Remove radiator outlet hose from water pump and from vehicle.
- Reverse procedure to install.
Upper
- Drain co...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1999 Chevrolet Tahoe AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1999 Chevrolet Tahoe 6.5 V8 DIESEL
- Open hood.
- Install a 3/8 inch drive wrench on tensioner arm.
- Rotate arm counterclockwise.
- On models equipped with a single alternator, remove driv...
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1999 Chevrolet Tahoe AUTOMOBILES
Component location diagrams for most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S. from 1990+.
Charging System Components Diagram for 1999 Chevrolet Tahoe 5.7 V8 GAS Components on diagram: |
A/C Components Diagram for 1999 Chevrolet Tahoe 5.7 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1999 Chevrolet Tahoe AUTOMOBILES
OEM drawn wiring diagrams for most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S.
1999 Chevrolet Tahoe 5.7 V8 GAS Wiring Diagram Components on diagram: |
1999 Chevrolet Tahoe 5.7 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1999 Chevrolet Tahoe AUTOMOBILES
OEM TSB listings for most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 1999 Chevrolet Tahoe 5.7 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1999 Chevrolet Tahoe AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1999 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1999 Chevrolet Tahoe SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1999 Chevrolet Tahoe vehicle. |
Access the Complete guide! |