Auto Parts Search
2002 Daewoo Leganza CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Daewoo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Daewoo Leganza car and truck
repair procedures including Daewoo engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Daewoo Leganza automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Daewoo -> Manual A/C & Heater System Diagnosis & Testing -> A/C System Diagnosis & Testing -> Insufficient Cooling -> Lanos & Leganza -> Leak Test -> Refrigerant System Tests
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
Lanos & Leganza
Insufficient Cooling
- Start and run engine at idle speed until it reaches operating temperature.
- Open hood and all doors.
- Turn A/C on and set temperature control knob to full cold.
- Set blower to highest speed setting.
- Feel evaporator outlet pipe, pipe should feel cold.
- If evaporator pipe does not feel cold, refer to insufficient cooling diagnostic chart in Fig. .
- If pipe does feel cold, check for other system problems, refer to "Refrigerant System Test" and "Leak Test."
Refrigerant Sys...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Disc Brakes -> Caliper Service -> Assemble -> Caliper, Overhaul -> Caliper, Replace -> Disassemble
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
Caliper, Replace
- Raise and support vehicle.
- Mark wheel to hub orientation, then remove wheel and tire.
- Remove brake fluid hose to caliper mounting bolt and washers, then the hose. Plug hose end and caliper port to prevent fluid loss and contamination.
- Remove caliper mounting bolts, then the caliper.
- Reverse procedure to install, noting the following:
- Tighten all nuts and bolts to specifications.
- Bleed brakes as outlined under "Brake System Bleed."
- Do not move vehicle until a firm brake pedal is obtained.
- Depress brake pedal several times to bring pads into contact with rotor.
Caliper, Overh...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Daewoo -> Fuel Filter Replacement -> All Models -> Fuel System Pressure Relief -> Installation -> Removal
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven 10 miles or more while it relearns its adaptive strategy.
Fuel System Pressure Relief
- Remove the fuel tank filler cap.
- On Lanos models, remove the fu...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
- Raise and support vehicle.
- Remove wheel nuts and front wheel.
- Remove hub nut.
- Remove ball joint to steering knuckle nut.
- Separate ball joint loose from steering knuckle.
- Push axle shaft out of steering knuckle and rotate knuckle forward.
- Pull axle shaft out of s...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Starter, Replace
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
- Disconnect battery ground cable.
- Remove intake manifold to block strap bracket over starter.
- Remove starter motor mounting bolts.
- Remove terminal nut, then disconnect electrical connectors and positive cable from starter solenoid.
- Remove starter from vehicle.
- Reverse procedure ...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Cabin Air Filter Service -> Daewoo -> 1999-2002 Leganza & Nubira
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
On 1999-2001 models, under normal operating conditions the cabin air filter should be replaced every 6 Months or 6,000 miles. In dusty areas change the cabin air filter more often. On 2002 models, under normal operating conditions the cabin air filter should be replaced every 6 Months or 7,500 miles. In dusty areas change the cabin air filter more often.
- Open the hood.
- Remove the two nuts securing the vacuum canis...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Daewoo -> Malfunction Indicator Lamp (MIL) ->
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
The MIL should illuminate when the ignition switch is placed in the on position to indicate the lamp is operational. After the engine has been started, the warning lamp should go off. If warning lamp comes on steady while the engine is running or while vehicle is being driven, a emission control related fault has been detected. After system diagnosis and repairs have been completed, the control module memory can be cleared...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure to inst...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Daewoo Leganza AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Daewoo Leganza AUTOMOBILES
Component location diagrams for most 2002 Daewoo Leganza cars and light trucks sold in the U.S. from 1990+.
 Front & Rear Door Wiring Harness Connector Locations Diagram for 2002 Daewoo Leganza 2.2 L4 GASComponents on diagram: |
 Anti-Lick Brake System & Traction Control System Component Locations Diagram for 2002 Daewoo Leganza 2.2 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Daewoo Leganza AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Daewoo Leganza cars and light trucks sold in the U.S.
 2002 Daewoo Leganza 2.2 L4 GAS Wiring DiagramComponents on diagram: |
 2002 Daewoo Leganza 2.2 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Daewoo Leganza AUTOMOBILES
OEM TSB listings for most 2002 Daewoo Leganza cars and light trucks sold in the U.S. from 1985+.
|
Document: SAFETY RECALL - CAMSHAFT POSITION SENSOR Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS Auto Systems: |
|
Document: SAFETY RECALL - CAMSHAFT POSITION SENSOR AND FUSE Vehicle: 2002 Daewoo Leganza 2.2 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Daewoo Leganza AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Daewoo Leganza cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Daewoo Leganza cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Daewoo Leganza cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Daewoo Leganza cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Daewoo Leganza SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2002 Daewoo Leganza vehicle.
|
| Access the Complete guide! |
