Auto Parts Search
2006 GMC Yukon Denali XL CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2006 GMC Yukon Denali XL car and truck
repair procedures including GMC engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your GMC Yukon Denali XL automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Anti-Lock Brakes -> Kelsey-Hayes -> System Service -> Brake Pressure Modulator Valve (BPMV) -> Brake System Bleed -> Component Replacement -> Electronic Brake Control Module (EBCM) -> Front Wheel Speed Sensor -> Manual Bleed -> Pressure Bleed
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
Brake System Bleed
Gravity and vacuum bleeding procedures are not recommended for use with the anti-lock brake system. The manual bleed procedure is the preferred method, although pressure bleeding is also possible. Do not pump the brake pedal during the bleeding process, as fluid aeration may occur.
Manual Bleed
- Raise and support vehicle, then connect a clear plastic tube to brake bleed screw at righthand rear wheel.
- Place free end of tube in a glass jar partially filled with clean brake fluid. Ensure end of tube remains submerged in fluid and master cylinder reservoir is kept full.
- ...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Component Locations -> 1999-06 Escalade, Avalanche & Denali, 1988-03 & C/K Pickup (Except 1999-03 Sierra & Silverado), 1992-06 Blazer, Jimmy, Hummer H2, SSR, Suburban, Yukon XL, Tahoe, Yukon, Bravada Gasoline Engines & 2004-06 Rainier, TrailBlazer & Envoy
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Remove drive axle center cap, if equipped.
- Insert a drift or large screwdriver through brake caliper into one of the brake rotor vanes in order to prevent drive axle wheel drive shaft from turning.
- Remove nut and washer from hub. Do not reuse nut. A new nut must be used when installing wheel drive shaft.
- Using J 45859 or equivalent, press wheel drive shaft from hub.
- Remove bolts securing wheel drive shaft ...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Component Replacement -> Installation -> Removal -> Tire Pressure Indicator Sensor (Clamp Style) -> Tire Pressure Indicator Sensor (Snap In Style)
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
Tire Pressure Indicator Sensor (Clamp Style)
Removal
- Loosen the lug nuts.
- Raise and support vehicle with jack stands, then remove the wheel and tire assembly.
- Prior to dismounting the tire from the wheel, note the following precautions:
- Position the bead breaking fixture 90° from the valve stem when separating the tire bead from the wheel.
- Place the mounting and dismounting head so that the tire iron or pry bar can be inserted slightly clockwise of the sensor body when prying the tire bead up and over the head.
- Rotate the tire and wheel assembly clockwise using the tire changer w...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Starter, Replace
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
- Disconnect battery ground cable.
- Remove mounting bolts and engine shield, if required.
- Remove mounting bolts and oil pan skid plate, if required.
- Remove righthand transmission cover bolt.
- Remove front axle mounting bracket nut, then position front axle mounting bracket bolt until tip is flush with support bushing. Do not remove bolt.
- Remove starter motor mounting bolts and slide starter forward until it clears transmission.
- Disconnect oil level sensor electrical connector.
- Remove starter...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Throttle Soon Indicator Lamp ->
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
A "Service Throttle Soon" indicator lamp is mounted in the lower righthand instrument cluster corner on these models. It lights when the ignition is turned On, but should go out approximately 1-5 seconds after the engine starts.
Traditional throttle cables are no longer used on these models. The PCM receives signals from an electron...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Radiator, Replace
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
- Drain radiator coolant into suitable container.
- Remove upper and lower radiator hoses.
- Remove mounting bolts and lower fan shroud.
- Remove engine vent hose and surge take hose.
- Disconnect engine oi...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 GMC Yukon Denali XL AUTOMOBILES
Component location diagrams for most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S. from 1990+.
 Wheel Speed Sensor Diagram for 2006 GMC Yukon Denali XL 6.0 V8 GASComponents on diagram: |
 RH Upper Instrument Panel Diagram for 2006 GMC Yukon Denali XL 6.0 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 GMC Yukon Denali XL AUTOMOBILES
OEM drawn wiring diagrams for most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S.
 2006 GMC Yukon Denali XL 6.0 V8 GAS Wiring DiagramComponents on diagram: |
 2006 GMC Yukon Denali XL 6.0 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 GMC Yukon Denali XL AUTOMOBILES
OEM TSB listings for most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS Auto Systems: |
|
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2006 GMC Yukon Denali XL 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 GMC Yukon Denali XL AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 GMC Yukon Denali XL cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Yukon Denali XL SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2006 GMC Yukon Denali XL vehicle.
|
| Access the Complete guide! |
