Auto Parts Search
2007 GMC Yukon XL 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> Power Brake Unit, Replace -> Acadia, Enclave & Outlook -> Avalanche, Escalade EXT, Sierra & Silverado -> Canyon & Colorado -> Envoy, Rainier & Trailblazer -> Equinox & Torrent -> Escalade, Suburban, Tahoe & Yukon -> Express & Savana -> HHR -> Hummer H2 -> Hummer H3 -> Relay, SV6, Terraza & Uplander -> Rendezvous -> SRX -> VUE
Vehicle: 2007 GMC Yukon XL 1500 Denali 6.2 V8 GAS
Acadia, Enclave & Outlook
- Apply park brake, then with engine off, apply and release brake pedal several times until brake pedal becomes firm to deplete vacuum reserve in vacuum brake booster.
- Remove air cleaner assembly.
- Disconnect master cylinder fluid level sensor electrical connector.
- Remove vacuum brake booster check valve and hose assembly from vacuum brake booster and position aside.
- Remove vacuum brake booster vacuum sensor and position aside.
- Release front and rear brake pipes from routing clip on frame rail.
- Remove Brake Pressure Modulator Valve (BPMV) assembly mount...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2007 GMC Yukon XL 1500 Denali 6.2 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Aids -> Diagnostic Check -> Diagnostic Tests -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Test Procedures
Vehicle: 2007 GMC Yukon XL 1500 SLE 5.3 V8 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Test Procedures
Refer to Figs. through for diagnostic test procedures.
Diagnostic Check
- Check for aftermarket devices which could affect the operation of the TPMS to verify that none are installed.
- Check the easily accessible or visible system components for obvious damage or conditions which could cause the symptom.
- Ensure that the scan tool selected front and rear tire pressure parameters are correct compared to the tire...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Alternator, Replace
Vehicle: 2007 GMC Yukon XL 1500 SLE 5.3 V8 FLEX
- Disconnect battery ground cable.
- Remove intake manifold sight shield from ball studs.
- Remove positive crankcase ventilation line from air cleaner outlet duct.
- Remove radiator inlet hose clamp retainer from outlet duct.
- Remove radiator vent inlet hose retainer from outlet duct.
- Loosen air cleaner outlet duct clamps at mass air flow intake air temperature sensor and at throttle body.
- Remove air cleaner outlet duct from throttle body and MAF/IA...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2007 GMC Yukon XL 1500 SLT 5.3 V8 FLEX
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Four Wheel Drive (4WD) System Warning Lamp ->
Vehicle: 2007 GMC Yukon XL 1500 SLE 6.0 V8 GAS
This lamp should light for approximately 6-8 seconds when the ignition is turned On as a bulb check. If the ...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 GMC Yukon XL 1500 SLE 5.3 V8 GAS
Lower
- Drain cooling system into a suitable container.
- Remove air cleaner assembly.
- Reposition hose clamp from thermostat housing using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from thermostat housing.
- Reposition hose clamp from radiator using hose clamp pliers J 38185 or equivalent.
- Remove rad...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 GMC Yukon XL 1500 SLE 5.3 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
Component location diagrams for most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S. from 1990+.
Front Body Components Diagram for 2007 GMC Yukon XL 1500 Denali 6.2 V8 GAS Components on diagram: |
Engine Compartment Diagram for 2007 GMC Yukon XL 1500 SLE 6.0 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S.
2007 GMC Yukon XL 1500 SLE 5.3 V8 GAS Wiring Diagram Components on diagram: |
2007 GMC Yukon XL 1500 SLE 5.3 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
OEM TSB listings for most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 GMC Yukon XL 1500 SLE 5.3 V8 FLEX Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2007 GMC Yukon XL 1500 SLE 5.3 V8 FLEX Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 GMC Yukon XL 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Yukon XL 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 GMC Yukon XL 1500 vehicle. |
Access the Complete guide! |