Audi RS4 REPAIR MANUAL -- HOW TO FIX YOUR CAR OR TRUCK

Auto Parts Search


Audi RS4 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Audi REPAIR SHOPS DON'T WANT YOU TO KNOW

Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!

Help me findSearch

Select Year

20082007

Get Full Access Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about Audi RS4 car and truck repair procedures including Audi engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up & drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix your Audi RS4 automobile. Try the Automotix DIY solution today!
DIY REPAIR SAMPLES > CONTINUE EXPLORING >
Using the Automotix DIY repair procedures will save you hundreds and even thousands of dollars! In addition, it will save you hours of touring the city searching for Audi mechanics you can trust. The Automotix DIY solution is particularly affordable. A full access to the entire DIY repair procedures and diagrams for your Audi RS4 vehicle will cost less than a single gallon of gas. Here are some of the DIY repair tips and procedures you will find here:

DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR Audi RS4 AUTOMOBILES

Includes CV axle, universal joint, and driveline replacement, for domestic and imported Audi RS4 cars and light trucks from 1990+.

DRIVESHAFT, Replace
Vehicle: 2007 Audi RS4 4.2 V8 GAS

  • Raise and support vehicle.
  • Remove rear section of exhaust system at clamp(s).
  • Pry off rear attachments of drive shaft heat shield.
  • Remove securing bolts for center bearing When removing securing bolts, support drive shaft by hand. Do not bend drive shaft.
  • Remove heat shield. Continue supporting drive shaft.
  • Screw in securing bolts for center bearing again hand-tight.
  • Remove drive shaft heat shield from transmission.
  • Check for a factory marking (colored dot) on drive shaft and on drive shaft flange on final drive at rear. If no colored dot is present, mark position of drive shaft fl...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES

TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR Audi RS4 AUTOMOBILES

Description, component locations, reset procedures, relearn procedures, diagnosis and testing, wiring diagrams, component replacement, and identification of vehicles equipped and not equipped with tire pressure monitoring system for most domestic and imported Audi RS4 cars and light trucks sold in the U.S. from mid 1990's+.

Reset Procedures
Vehicle: 2008 Audi RS4 Cabriolet 4.2 V8 GAS

  • Check and the adjust tire pressure to the manufacturer's specifications.
  • Press the Reset button located on the windshield wiper control lever until DISPLAY TYPE appears on the instrument cluster.
  • Press button on end of the windshield wiper control lever to select SET option.
  • Press the Reset button on the windshield wiper control lever.
  • Press button on end of the wi...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 TIRE PRESSURE MONITORING SYSTEM PROCEDURES

STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR Audi RS4 AUTOMOBILES

Includes starter and alternator replacement procedures for domestic and imported Audi RS4 cars and light trucks from 1990+.

Starter, Replace
Vehicle: 2008 Audi RS4 4.2 V8 GAS

  • Disconnect battery ground cable.
  • Remove rear noise insulation.
  • Remove electrical connector from solenoid.
  • Remove terminal B+ protective cap.
  • Remove nut and terminal B+ from solenoi...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 STARTER & ALTERNATOR REPLACEMENT PROCEDURES

CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR Audi RS4 AUTOMOBILES

Cabin air filter locations and replacement procedures with corresponding images for most domestic and imported Audi RS4 cars and light trucks sold in the U.S. as equipped to the current model year.

Cabin Air Filter Service -> Audi -> 1996-2008 A4, 1998 Cabriolet, 2002-08 S4 & 2007-09 RS4
Vehicle: 2008 Audi RS4 Cabriolet 4.2 V8 GAS

On 1996-2003 models, the cabin air filter should be replaced every 20,000 miles.

On 2004-09 models, the cabin air filter should be replaced at 15,000 miles, then every 20,000 miles.

  • Open the hood.
  • Remove the righthand side air intake pl...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES

MAINTENANCE LAMP RESET PROCEDURES FOR Audi RS4 AUTOMOBILES

Maintenance lamp reset procedures with corresponding images for most domestic and imported Audi RS4 cars and light trucks sold in the U.S. from 1990+.

Audi -> Auto-Check Indicator System ->
Vehicle: 2007 Audi RS4 4.2 V8 GAS

The auto-check system will monitor certain vehicle systems when the ignition switch is placed in the On position and vehicle is operated. When all monitored systems are functioning properly, the system display will indicate "OK" for a few seconds after the ignition switch is placed in the On position.

This system monitors brake fluid level and hydraulic pressure, engine oil pressure, coolant temperature and level, brake pad wear, headlamps and tail lamps, battery voltage, washer fluid level and fuel level.

When the auto-check yellow or r...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 MAINTENANCE LAMP RESET PROCEDURES

RADIATOR & HOSE REPLACEMENT PROCEDURES FOR Audi RS4 AUTOMOBILES

Includes radiator, cooling and heater hose replacement procedures for domestic and imported Audi RS4 cars and light trucks from 1990+

Radiator, Replace
Vehicle: 2007 Audi RS4 4.2 V8 GAS

  • Remove front engine cover.
  • Open cap of coolant expansion tank.
  • On models with auxiliary heater, remove bolts for parking heater/auxiliary heater exhaust pipe on sound insulation.
  • Loosen quick-release fasteners and remove front sound insulation. Rear section of sound insulation remains installed.
  • Remove front bumper cover.
  • Disconnect coolant hose from lower left of radiator and drain engine coolant, using a suitable container.
  • Disconnect coolant hose from lower right of radiator.
  • Disconnect top coolant hose from radiator.
  • On models with automatic transmission, proceed as follows:
    • Remove...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 RADIATOR & HOSE REPLACEMENT PROCEDURES

SERPENTINE BELT SERVICE PROCEDURES FOR Audi RS4 AUTOMOBILES

Serpentine belt replacement procedures with corresponding images for most domestic and imported Audi RS4 cars and light trucks sold in the U.S. from 1990+.

Serpentine Drive Belt, Replace
Vehicle: 2008 Audi RS4 4.2 V8 GAS

  • Raise and support vehicle.
  • Remove quick-release fasteners, screws, and noise insulation.
  • Mark direction of rotation of drive belt with chalk or felt pen, if belt is t...

CLICK HERE TO GET FULL ACCESS TO Audi RS4 SERPENTINE BELT SERVICE PROCEDURES

COMPONENT LOCATION DIAGRAMS FOR Audi RS4 AUTOMOBILES

Component location diagrams for most Audi RS4 cars and light trucks sold in the U.S. from 1990+.

Body Components Diagram for 2007 Audi RS4  4.2 V8 GASBody Components Diagram for 2007 Audi RS4 4.2 V8 GAS

Components on diagram:
  • Compressor
  • Condenser
  • Heated Windshield Control Module
  • Outside Air Temperature Sensor
  • Coolant Fan Control Module
  • Body Components Diagram for 2008 Audi RS4  4.2 V8 GASBody Components Diagram for 2008 Audi RS4 4.2 V8 GAS

    Components on diagram:
  • Antenna
  • Left Antenna Module
  • Front Midrange Speaker
  • Satellite Radio
  • R108
  • CLICK HERE TO GET FULL ACCESS TO Audi RS4 PARTS/COMPONENTS LOCATION DIAGRAMS!

    WIRING DIAGRAMS FOR Audi RS4 AUTOMOBILES

    OEM drawn wiring diagrams for most Audi RS4 cars and light trucks sold in the U.S.

    2008 Audi RS4  4.2 V8 GAS Wiring Diagram2008 Audi RS4 4.2 V8 GAS Wiring Diagram

    Components on diagram:
  • Driver Backrest Adjustment Switch
  • Driver Seat Height Adjustment Motor
  • Driver Seat Height Adjustment Switch
  • Driver Seat Inclination Adjustment Motor
  • Driver Backrest Seat Tilt Switch
  • 2007 Audi RS4  4.2 V8 GAS Wiring Diagram2007 Audi RS4 4.2 V8 GAS Wiring Diagram

    Components on diagram:
  • Throttle Valve Control Module
  • Oxygen Sensor
  • Mass Air Flow Sensor
  • Knock Sensor
  • Fuel Injectors
  • CLICK HERE TO GET FULL ACCESS TO Audi RS4 WIRING DIAGRAMS!

    TECHNICAL SERVICE BULLETINS FOR Audi RS4 AUTOMOBILES

    OEM TSB listings for most Audi RS4 cars and light trucks sold in the U.S. from 1985+.

    Document: ENGINE OIL, OIL QUALITY STANDARD - REVISED
    Vehicle: 2007 Audi RS4 4.2 V8 GAS

    Auto Systems:
  • Chemicals, Antifreeze, Additives
  • Gasoline Engines
  • Document: VEHICLE LACKS POWER OR WILL NOT MOVE AFTER STOP - REVISED
    Vehicle: 2008 Audi RS4 4.2 V8 GAS

    Symptoms:
  • Driveability
  • Auto Systems:
  • Fuel Sys, Driveability, Filters (Air & Fuel)
  • CLICK HERE TO GET FULL ACCESS TO Audi RS4 TECHNICAL SERVICE BULLETINS!

    COMPONENT/PARTS SPECIFICATIONS FOR Audi RS4 AUTOMOBILES

    BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most Audi RS4 cars and light trucks sold in the U.S. and Canada from 1970+.

    • Brake caliper mounting bolt torque
    • Brake drum runout, machining, & discard specs
    • Minimum brake lining thickness.
    • Brake rotor runout, parallelism, machining, discard, & finish specs

    A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most Audi RS4 cars and light trucks sold in the U.S. and Canada from 1980+.

    • Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap

    COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.

    PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules

    QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most Audi RS4 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.

    • Automatic transmission/transaxles capacities, lubricant recommendations
    • Differential/final drive capacities, lube recommendations, grades, & viscosities
    • Final drive fill & drain plug torques
    • Number of lubrication fittings & plugs
    • Power steering, brake, & clutch fluid recommendations
    • Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
    • Number of lubrication fittings & plugs
    • Power steering, brake, & clutch fluid recommendations
    • Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
    • Severe service maintenance & interval recommendations
    • Tire sizes, wheel nut/bolt torque, pressures & rim sizes
    • Transfer case capacities, lube recommendations, grades, & viscosities

    TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most Audi RS4 cars and light trucks sold in the U.S. and Canada from 1980+

    • Airflow sensor electrical specifications
    • Tensioning specifications for systems with automatic tensioners
    • Barometric pressure sensor specs
    • Battery group number and cranking performance
    • Crankshaft & camshaft position sensor resistance
    • Engine compression pressures
    • Coolant temperature sensor specs
    • Computer advance.
    • Diesel fuel temperature sensor resistance.
    • Distributor advance specifications
    • Ignition pickup coil resistance
    • Exhaust gas recirculation temperature sensor resistance
    • Engine fastener torque values
    • Firing order diagrams
    • Fuel system pressures
    • Generator (alternator) specs
    • Intake air temperature sensor specs
    • Ignition coil specifications
    • Fuel injector resistance
    • Engine idle speeds
    • Knock sensor resistance
    • Manifold absolute pressure sensor specs
    • Mixture control solenoid resistance
    • Voltage regulator specs
    • Spark plug applications & gaps
    • Starter motor electrical specs.
    • Tensioning specifications for systems without automatic tensioners
    • Throttle body temperature sensor resistance
    • Ignition timing in degrees at rpm
    • Transmission oil temperature sensor resistance
    • Throttle position sensor specs
    • Vacuum sensor valve specs

    CLICK HERE TO GET FULL ACCESS TO Audi RS4 SPECIFICATIONS DATA!

    Shop online for auto body parts, engines, wheels, lights...

    More parts
    Help me findSearch
    Auto Repair Quick Search
    Help me find
    Search DIY repair manuals by VIN...
    Vehicle Identification Number is a unique serial number used by the automotive industry to identify individual motor vehicles

    Find out what info we have for your vehicle

    Get the Complete Technical Service Bulletins!
    Get the Complete Technical Service Bulletins!Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your Audi RS4 vehicle.
    Access the Complete guide!
    Need To Fix Your Car or Truck?
    Save Money With Free Car Insurance Quote
    FREE car insurance quote
    Enter Zip Code:
    Auto Repair Quick Search
    Help me find