Auto Parts Search
1993 Chevrolet Caprice CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
Cooling Fans -> Passenger Cars Except Saturn -> BERETTA & CORSICA -> 2.2L & 3.1L Engines -> 2.3L Engine -> COMPONENT REPLACEMENT -> Coolant Fan Does Not Run At All -> Coolant Fan Does Not Turn Off With Ignition Switch In Run -> COOLING FAN, REPLACE -> DESCRIPTION -> System Check -> System Diagnosis -> SYSTEM DIAGNOSIS & TESTING -> TROUBLESHOOTING
Vehicle: 1993 Chevrolet Caprice Classic 5.0 V8 GAS
DESCRIPTION
Voltage is available at all times through fusible link A to coolant fan relay contacts. With ignition switch in Run position, voltage is available through fuse 9 to coolant fan relay coil. When the ECM receives a signal from coolant temperature sensor, ground is provided for coolant fan relay by module's coolant fan terminal. Voltage is applied through fuse 9 to coolant fan relay coil. When ECM grounds the circuit, coolant fan relay contacts close and voltage is applied through coolant fan relay contacts to coolant fan and the fan runs.
When refrige...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
Power Brake Units -> Adjustments -> AC-Delco Type -> AIR METHOD -> BRAKE PEDAL -> GAUGE METHOD -> PUSHROD -> Single Diaphragm Type -> Toyota/GM Single Diaphragm Type
Vehicle: 1993 Chevrolet Caprice Classic 4.3 V6 GAS
BRAKE PEDAL
Toyota/GM Single Diaphragm Type
- With engine running and brake pedal in rest position, measure distance between face of pedal and floor mat.
- If distance is not 5.79-6.18 inches, adjust pedal height as follows:
- Remove left lower instrument panel trim section and air duct.
- Loosen stop lamp switch sufficiently to gain clearance for pedal adjustment.
- Loosen locknut and rotate pedal pushrod as needed to obtain specified pedal height, then tighten locknut.
- Adjust position of brake light switch so that plunger lightly contacts pedal stopper and brake lamps are off when pedal is release...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Replacement -> Except Aveo, Chevette 1.8L Diesel, Corvette, GTO, LaCrosse, Malibu (2004-06) & Malibu Maxx, Vibe, XLR, 2004-05 Corvette & 1998-2002 Metro & Prizm
Vehicle: 1993 Chevrolet Caprice Classic 4.3 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the v...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 1993 Chevrolet Caprice Classic 5.0 V8 GAS
- Raise and support vehicle.
- Mark position of shaft in relation to pinion flange for reassembly.
- Remove straps securing universal joint to pinion flange, then disconnect shaft from flange. Tape bearing cups to universal joint to prevent loss of ne...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
Alternator, Replace
Vehicle: 1993 Chevrolet Caprice Classic LTZ 5.7 V8 GAS
- Disconnect battery ground cable.
- Disconnect positive cable from alternator BAT terminal.
- Remove nut and bolt from upper brace.
- Loosen nut and move upper brace out of way.
- Remove bolt, nut and rear brace.
- Remove nuts, bolt and also lower brace.
- Remove engine harness electrica...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
General Motors Corp./Saturn Cars -> Low Washer Fluid Indicator ->
Vehicle: 1993 Chevrolet Caprice Classic 4.3 V6 GAS
The windshield washer solvent tank has a switch that closes when the wash...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 1993 Chevrolet Caprice Classic LS 5.0 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at engine inlet manifold using hose clamp pliers.
- Remove heater inlet hose from engine inlet manifold.
- Reposition heater core inlet hose clamp at heater core using hose clamp pliers.
- Remove hose from vehicle.
- Reverse pr...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1993 Chevrolet Caprice AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1993 Chevrolet Caprice Classic 4.3 V6 GAS
- Disconnect battery ground cable.
- Using suitable 1/2 inch ...
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1993 Chevrolet Caprice AUTOMOBILES
Component location diagrams for most 1993 Chevrolet Caprice cars and light trucks sold in the U.S. from 1990+.
Front Frame Rail Diagram for 1993 Chevrolet Caprice Classic 4.3 V6 GAS Components on diagram: |
Rear RH Side of Engine Compartment Diagram for 1993 Chevrolet Caprice Classic 4.3 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1993 Chevrolet Caprice AUTOMOBILES
OEM drawn wiring diagrams for most 1993 Chevrolet Caprice cars and light trucks sold in the U.S.
1993 Chevrolet Caprice Classic LTZ 5.7 V8 GAS Wiring Diagram Components on diagram: |
1993 Chevrolet Caprice Classic LTZ 5.7 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1993 Chevrolet Caprice AUTOMOBILES
OEM TSB listings for most 1993 Chevrolet Caprice cars and light trucks sold in the U.S. from 1985+.
Document: Car and Truck Fix It Right the First Time Issues Vehicle: 1993 Chevrolet Caprice Classic 5.0 V8 GAS Auto Systems: |
Document: Air Conditioning Compressor Replacement - Diagnosis Vehicle: 1993 Chevrolet Caprice Classic 5.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1993 Chevrolet Caprice AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1993 Chevrolet Caprice cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1993 Chevrolet Caprice cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1993 Chevrolet Caprice cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1993 Chevrolet Caprice cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1993 Chevrolet Caprice SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1993 Chevrolet Caprice vehicle. |
Access the Complete guide! |