Auto Parts Search
1994 Pontiac Firebird CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 1994 Pontiac Firebird car and truck
repair procedures including Pontiac engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Pontiac Firebird automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
Computer Relearn Procedures -> General Motors Corp. -> 1997-98 -> 1998-2000 -> 1998-99 -> 1999-2001 -> 1999-2002 -> 2.2L & 2.4L Engines -> 2000-02 -> 2000-04 -> 2001-02 -> 2001-04 -> 3.1L, 3.4L, 3800/3.8L, 4.0L & 4.6L Engines -> 3.5L Engine -> 5.7L Engine -> Achieva, Alero, Grand Am & Skylark -> Achieva, Cavalier, Skylark & Sunfire -> Alero & Grand Am -> Alero & Malibu -> Aurora -> Aurora, Bonneville, DeVille, LeSabre & Seville -> Aurora, Bonneville, Grand Prix, LeSabre & Park Avenue -> Auto Learn Passlock Procedure -> Body Control Module (BCM) -> Bonneville -> Bonneville, Eighty Eight, LeSabre, LSS & Park Avenue -> C & K Series w/Diesel Engine -> C & K Trucks w/Diesel Engine -> Camaro & Firebird -> Catera -> Cavalier & Sunfire -> Century -> Century, Grand Prix, Impala, Intrigue, Lumina, Monte Carlo & Regal -> Century, Impala, Intrigue, Monte Carlo & Regal -> Corvette -> Crankshaft Position System Variation Learn -> Cutlass & Malibu -> Dash Integration Module (DIM) -> DeVille -> DeVille, Eldorado & Seville -> EEPROM -> Eldorado -> Engine Control Module (ECM) -> Engine Performance -> Except Park Avenue -> Grand Am -> Grand Prix & Regal -> Impala & Monte Carlo -> Instrument Panel Integration Module (IPM) -> Intrigue -> LeSabre -> Less Tech 2 Or Techline Terminal -> Light Truck & Vans -> Park Avenue -> Passenger Cars -> Passkey Module -> Passlock Learn Procedure -> PCM -> Powertrain Control Module (PCM) -> Powertrain Control Module (PCM) & Vehicle Control Module (VCM) -> Rear Integration Module -> Riviera -> Seville -> T50/T60/T20+ -> TDC Offset Adjustment -> Theft Deterrent System Programming -> VCM -> With Tech 2 -> With Techline Terminal & Scan Tool
Vehicle: 1994 Pontiac Firebird Trans AM GT 5.7 V8 GAS
Passenger Cars
Body Control Module (BCM)
Alero & Grand Am
This procedure must be performed if the BCM, Passlock sensor or PCM is replaced. If BCM is not properly programmed, it will not control all the features properly.
- Ensure battery is fully charged and ignition switch is in the ON position.
- Connect a suitably programmed Tech II, or equivalent, scan tool to Data Link Connector (DLC).
- Access scan tool "Special Functions" menu and follow scan tool instructions to program BCM.
- If BCM fails to accept the pr...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
Power Brake Units -> Description -> AC-DELCO SINGLE DIAPHRAGM TYPE -> AC-DELCO TANDEM DIAPHRAGM TYPE -> BCIA SINGLE & TANDEM DIAPHRAGM TYPE
Vehicle: 1994 Pontiac Firebird 3.4 V6 GAS
AC-DELCO TANDEM DIAPHRAGM TYPE
This unit utilizes a vacuum power chamber, consisting of a front and rear shell, housing divider, front and rear diaphragm, plate assemblies, hydraulic pushrod and a diaphragm return spring, Figs. and .
The unit operates in much the same manner as the single diaphragm unit described previously. The diaphragm and plate assemblies utilize the pressure differential between the engine intake manifold vacuum and atmospheric pressure to assist in braking.
AC-DELCO SINGLE DIAPHRAGM TYPE
The AC-Delco power booster assembly, Fig. is located along the bulkhead in ...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Pressure Relief -> Except Aveo, LaCrosse, LeMans (1988-93), Malibu & Malibu Maxx (2004-05), Metro, Nova, Prizm, Spectrum & Storm -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 1994 Pontiac Firebird 3.4 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strateg...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 1994 Pontiac Firebird Trans AM 5.7 V8 GAS
- Raise and support vehicle.
- Mark position of shaft in relation to pinion flange for reassembly.
- Remove straps securing universal joint to pinion flange, then disconnect shaft from flange. Tape bearing cups to universal joint to pre...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
Starter, Replace -> Installation -> Removal
Vehicle: 1994 Pontiac Firebird Formula 5.7 V8 GAS
Removal
This vehicle was designed for starter mounting without shims. If single or double shims have been added to correct a noise or engagement problem, they should be reinstalled in their original positions to ensure proper pinion to flywheel assembly engagement.
- Disconnect battery ground cable, then raise and support vehicle.
- Disconnect exhaust crossover pipe at manifolds, then remove starter motor mounting bolts and lower starter motor assembly, Fig. .
- Disconnect electrical connectors from starter motor assembly, then remove starter motor assembly.
Installation
Before conn...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
General Motors Corp./Saturn Cars -> Active Handling System Warning Lamp ->
Vehicle: 1994 Pontiac Firebird Trans AM 5.7 V8 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned on as a bulb check. The lamp will also come on as the system is...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
Radiator, Replace
Vehicle: 1994 Pontiac Firebird 3.4 V6 GAS
- Disconnect intake duct, then remove air cleaner assembly.
- Remove mass air flow sensor (MAF), if equipped.
- Raise and support vehicle, then drain engine coolant.
- Disconnect electrical connectors at cooling fans.
- Remove upper radiator mounting panel, then cooling fan assembly.
- Disconnect oi...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1994 Pontiac Firebird AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1994 Pontiac Firebird 3.4 V6 GAS
- Disconnect battery ground cable.
- Lift belt tensioner off belt using a socket and breaker bar.
- Remove drive belt.
- Reverse procedure to install, noting the following:
- Start and operate engine for 5 minutes. Check belt tension using a suitable belt tension gauge.
- On m...
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1994 Pontiac Firebird AUTOMOBILES
Component location diagrams for most 1994 Pontiac Firebird cars and light trucks sold in the U.S. from 1990+.
 RH Side Under Console Diagram for 1994 Pontiac Firebird Trans AM 5.7 V8 GASComponents on diagram: |
 Bottom of Steering Column Diagram for 1994 Pontiac Firebird 3.4 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1994 Pontiac Firebird AUTOMOBILES
OEM drawn wiring diagrams for most 1994 Pontiac Firebird cars and light trucks sold in the U.S.
 1994 Pontiac Firebird 3.4 V6 GAS Wiring DiagramComponents on diagram: |
 1994 Pontiac Firebird Trans AM GT 5.7 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1994 Pontiac Firebird AUTOMOBILES
OEM TSB listings for most 1994 Pontiac Firebird cars and light trucks sold in the U.S. from 1985+.
|
Document: Car and Truck Fix It Right the First Time Issues Vehicle: 1994 Pontiac Firebird 3.4 V6 GAS Auto Systems: |
|
Document: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust Vehicle: 1994 Pontiac Firebird 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1994 Pontiac Firebird AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1994 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1994 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1994 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1994 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1994 Pontiac Firebird SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
