Auto Parts Search
1994 Toyota Celica CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
Toyota -> Manual Air Conditioning & Heater System Diagnosis & Testing -> REFRIGERANT CHARGE
Vehicle: 1994 Toyota Celica GT 2.2 L4 GAS
To check the refrigerant charge, allow engine to run at fast idle and operate air conditioner at maximum cooling for severa...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
POWER BRAKE UNITS -> DIAGNOSIS & TESTING -> Air Tightness Check -> Brake Booster Operational Test -> Operating Check
Vehicle: 1994 Toyota Celica ST 1.8 L4 GAS
Brake Booster Operational Test
Operating Check
- Depress brake pedal several times with engine stopped, and ensure pedal reserve distance has no change, Fig. .
- Depress brake pedal and start engine. If pedal drops slightly, operation is normal.
Air Tightness Check
- Start engine and stop after one or two minutes.
- Depress brake peda...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
Toyota -> Component Locations -> 1986-99 Celica
Vehicle: 1994 Toyota Celica 1.8 L4 GAS
Refer to Fig...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1994 Toyota Celica GT 2.2 L4 GAS
- Raise and support vehicle, then remove front wheels as necessary and front fender apron seal.
- Remove cotter pin, locknut cap and locknut from axle spline.
- Drain transmission fluid, then using a suitable puller, disconnect tie rod end from steering knuckle.
- Disconnect stabilizer bar link from lower control arm.
- Disconnect ball joint from steering knuckle.
- To separate LH driveshaft from transmission, gently pry shaft out of transaxle with suitable tool, then remove snap ring from splined end of side gear shaft.
- To separate RH driveshaft from transmission proceed as follows:
- Remove...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
Starter, Replace
Vehicle: 1994 Toyota Celica GT 2.2 L4 GAS
- Disconnect battery ground cable.
- Obtain audio anti-theft code, if equipped.
- Remove air cleaner case assembly as follows:
- Disconnect air intake temperature sensor connector.
- Disconnect four air cleaner cap clips.
- Disconnect air cleaner hose from throttle body and remove air cleaner cap and filter element.
- Remove three air cleaner case retaining bolts, then case.
- Remove engine compartment relay box as follows:
- Remove two relay box retaining nuts and disconnect relay box from battery.
- Remove low...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
Toyota -> Automatic Transmission Oil Temperature Warning Lamp ->
Vehicle: 1994 Toyota Celica 1.8 L4 GAS
This lamp will be illuminated when automatic transmission or transfer case fluid temperature exceeds 302°F. If the lamp lights, allow vehicle to operate at idle speed until fluid temperature falls below 248°F; t...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 1994 Toyota Celica GT 2.2 L4 GAS
Inlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater core.
- Remove hose from heater core.
- Reposition hose clamp at water outlet.
- Remove hose from water outlet.
- Remove hose from vehicle.
- Reverse procedure ...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1994 Toyota Celica AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1994 Toyota Celica ST 1.8 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1994 Toyota Celica AUTOMOBILES
Component location diagrams for most 1994 Toyota Celica cars and light trucks sold in the U.S. from 1990+.
Grounds & Harness To Harness Connector Locations (Passenger Compartment) Diagram for 1994 Toyota Celica ST 1.8 L4 GAS Components on diagram: |
Harness To Harness Connector Locations (Instrument Panel) Diagram for 1994 Toyota Celica 1.8 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1994 Toyota Celica AUTOMOBILES
OEM drawn wiring diagrams for most 1994 Toyota Celica cars and light trucks sold in the U.S.
1994 Toyota Celica 1.8 L4 GAS Wiring Diagram Components on diagram: |
1994 Toyota Celica 1.8 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1994 Toyota Celica AUTOMOBILES
OEM TSB listings for most 1994 Toyota Celica cars and light trucks sold in the U.S. from 1985+.
Document: SEAT BELT TONGUE PLATE STOPPER REPLACEMENT - REVISED Vehicle: 1994 Toyota Celica GT 2.2 L4 GAS Auto Systems: |
Document: REPLACEMENT CERTIFICATION LABELS - REVISED Vehicle: 1994 Toyota Celica GT 2.2 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1994 Toyota Celica AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1994 Toyota Celica cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1994 Toyota Celica cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1994 Toyota Celica cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1994 Toyota Celica cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1994 Toyota Celica SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1994 Toyota Celica vehicle. |
Access the Complete guide! |