Auto Parts Search
1995 Mercury Tracer CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Mercury REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
General Service Domestic Vehicles -> 1994-95 -> Exercise System
Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS
An important fact most car owners ignore is that the A/C system must be used periodically. Car manufacturers caution that when the air conditioner is not used regularly, particularly during cold months, it should be turned on for a few minutes once every two or three weeks while the engine is running. This keeps the system in good operating condition.
Checking out the system for the effects of disuse before the onset of summer is one of the most important asp...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
Anti-lock Brakes -> Aspire, Escort & Tracer -> System Service -> ABS Control Module -> Anti-Lock Relay -> Aspire -> Brake Pressure Control Valve -> Brake System Bleed -> Component Replacement -> Escort & Tracer -> Front Brake Anti-Lock Sensor Indicator -> Front Brake Anti-Lock Sensors -> Hydraulic Anti-Lock Actuator Assembly -> Rear Brake Anti-Lock Sensor Indicator -> Rear Brake Anti-Lock Sensors
Vehicle: 1995 Mercury Tracer Trio 1.9 L4 GAS
Brake System Bleed
- Disconnect 55-pin plug from ABS module (ECU), then attach anti-lock breakout box/bleeding adapter tool No. T90P-50-ALA, or equivalent, to wiring harness 55-pin plug.
- Place bleed/harness switch in bleed position.
- Turn ignition to On position. Red Off light should turn on.
- Push motor button on adapter down to start pump motor. Red Off light will turn off and green On light will turn on. Pump motor will run for 60 seconds once motor button is pushed.
- If pump motor is turns off before 60 seconds has elapsed, push abort button and pump motor will turn off.
- After 20 second...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
Ford Motor Co. Passenger Cars -> Fuel Filter Replacement -> Except 2002-05 Thunderbird, 2000-06 LS, 1984-87 Escort, Tracer, Tempo & Topaz 2.0L Diesel Engine & 1984-85 Continental & Mark VI 2.4L Diesel Engine
Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
When installing the fuel filter, ensure the flow arrow is facing in the pro...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS
If removing both right and left side halfshafts, appropriate plugs must be installed. Failure to do so may result in dislocation of differential side gears, necessitating transaxle disassembly to re-align gears.
- Raise and support vehicle.
- Remove wheel and splash shield.
- Raise staked portion of halfshaft retaining nut using suitable tool.
- Remove retaining nut and discard.
- Remove cotter pin from tie rod end and separate tie rod end from steering knuckle using a suitable tie rod remover tool.
- Remove lower ball joint clamp bolt and pry down on lower control arm to separate ball joi...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
Starter, Replace
Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS
- Disconnect battery ground cable.
- Remove air duct from throttle body to resonance chamber.
- Remove starter motor upper mounting bolts, then raise and support vehicle.
- Remove intake plenum support bracket, then disconnect S terminal connector from starter solenoid. When disconnecting connector from S terminal, grasp con...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
Ford Motor Co. Cars -> Low Coolant Lamp ->
Vehicle: 1995 Mercury Tracer Trio 1.9 L4 GAS
The low coolant warning lamp should light whenever the coolant level in the coolant recovery bottle is 1/4 to 3/4 inch or more below the cold full mark. Raise coolant level in recovery bottle to the cold full mark to turn lamp off.
On models equipped with GEM module and low coolant level warning system, t...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator using hose clamp pliers.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from water pump using hose clamp pliers.
- Remove radiator outlet hose from water pump and from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1995 Mercury Tracer AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1995 Mercury Tracer Trio 1.9 L4 GAS
- Insert a 3/8 inch drive ratchet or breaker bar onto tensioner.
- Rotate or lift tensioner to relieve te...
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1995 Mercury Tracer AUTOMOBILES
Component location diagrams for most 1995 Mercury Tracer cars and light trucks sold in the U.S. from 1990+.
Body Components Diagram for 1995 Mercury Tracer Trio 1.9 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1995 Mercury Tracer AUTOMOBILES
OEM drawn wiring diagrams for most 1995 Mercury Tracer cars and light trucks sold in the U.S.
1995 Mercury Tracer Trio 1.9 L4 GAS Wiring Diagram Components on diagram: |
1995 Mercury Tracer Trio 1.9 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1995 Mercury Tracer AUTOMOBILES
OEM TSB listings for most 1995 Mercury Tracer cars and light trucks sold in the U.S. from 1985+.
Document: RECALL - CERTAIN 1992-2003 MODEL YEAR CARS AND TRUCKS - FUSED JUMPER HARNESS REPLACEMENT FOR VEHICLES SERVICED WITH AN INCOMPATIBLE FUSED JUMPER HARNESS Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS Auto Systems: |
Document: RECALL - 1992-2004 MULTIPLE VEHICLE LINES - SPEED CONTROL SYSTEM MODIFICATION Vehicle: 1995 Mercury Tracer LTS 1.8 L4 GAS |
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1995 Mercury Tracer AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1995 Mercury Tracer cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1995 Mercury Tracer cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1995 Mercury Tracer cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1995 Mercury Tracer cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1995 Mercury Tracer SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1995 Mercury Tracer vehicle. |
Access the Complete guide! |