Auto Parts Search
1996 Mercury Mystique CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Mercury REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Drive Belt Data -> Domestic Passenger Cars -> 1996-97
Vehicle: 1996 Mercury Mystique GS 2.5 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Power Brake Units -> Adjustments -> Bendix Type -> Pushrod -> Single Diaphragm Booster
Vehicle: 1996 Mercury Mystique GS 2.0 L4 GAS
Pushrod
Proper adjustment of the master cylinder pushrod is necessary to ensure proper operation of the power brake system. A pushrod that is too long will prevent the master cylinder piston from completely releasing hydraulic pressure, eventually causing the brakes to drag. A pushrod that is too short will cause excessive brake pedal travel and cause groaning noises to come from the booster when the brakes are applied. A properly adjusted pushrod that remains assembled to the booster with which is was matched during production should not require service adjustment. However, if the b...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Ford Motor Co. Passenger Cars -> Component Locations -> 1995-00 Contour & Mystique & 1999-02 Cougar
Vehicle: 1996 Mercury Mystique GS 2.5 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
CV AXLE SHAFT, Replace -> Intermediate -> Left -> Right
Vehicle: 1996 Mercury Mystique LS 2.5 V6 GAS
Left
- Use an Allen key to stop piston rod from turning.
- Loosen suspension strut nut five turns.
- Loosen wheel hub retaining nut and wheel nuts.
- Raise and support vehicle.
- Remove wheel.
- Remove wheel hub retaining nut.
- On models with automatic transaxle, drain automatic transmission fluid.
- On all models, remove splash shields.
- Detach suspension.
- Disconnect stabilizer link end from suspension strut.
- Disconnect tie-rod end.
- Disconnect lower suspension arm from wheel knuckle.
- Disconnect wiring harness bracket from suspension strut.
- To avoid damage to CV joints and boots, do not bend inner CV ...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Alternator, Replace
Vehicle: 1996 Mercury Mystique LS 2.5 V6 GAS
- Disconnect battery ground cable.
- Disengage alternator drive belt from alternator pulley.
- Raise and support vehicle, then remove righthand wheel and tire.
- Remove righthand outer tie rod end from righthand spindle.
- Remove front and rear Y pipe flange fasteners from exhaust manifolds.
- Remove stud bolt and nut retainer from oil pan, then remove remaining nuts and bolts from U pipe outlet connection.
- Discard exhaust converter inlet gasket, then remove Y pipe.
- Disconnect wire harness attachment...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Cabin Air Filter Service -> Ford Motor Co. -> 1995-97 Contour & Mystique
Vehicle: 1996 Mercury Mystique LS 2.0 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Position windshield wipers away from the cowl vent screen. Operate the windshield wipers until the blades are at the top of their arch, then place the ignition switch in the Off position.
- Remove the plastic screw covers from the righthand cowl panel retaining screws.
- Open the hood.
- Remove the righthand cowl panel retaining screws, then the panel.
- Disengage...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Ford Motor Co. Cars -> Check Fuel Cap Lamp ->
Vehicle: 1996 Mercury Mystique LS 2.5 V6 GAS
The Check Fuel Cap Lamp will illuminate momentarily when the ignition switch is placed in the On position as a bulb check. If the lamp remains...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 1996 Mercury Mystique LS 2.5 V6 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Reposition heater core inlet hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1996 Mercury Mystique AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1996 Mercury Mystique LS 2.5 V6 GAS
- On water pump drive belt, remove water pump pulley shield bolts from lefthand valve cover, then the shield from vehicle.
- Remove water pump drive pulley, then rotate water pump belt tensioner clockwise by hand.
- On accessory drive belt, rotate tensioner clockwise using breaker bar installed in 3/8 inch square hole in drive belt tensioner arm.
- On all drive belts, lift belt over pulley flanges, then remove from vehicle.
- On accessory drive ...
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1996 Mercury Mystique AUTOMOBILES
Component location diagrams for most 1996 Mercury Mystique cars and light trucks sold in the U.S. from 1990+.
Body Component Locations Diagram for 1996 Mercury Mystique LS 2.5 V6 GAS Components on diagram: |
Engine Compartment Component Locations Diagram for 1996 Mercury Mystique LS 2.0 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1996 Mercury Mystique AUTOMOBILES
OEM drawn wiring diagrams for most 1996 Mercury Mystique cars and light trucks sold in the U.S.
1996 Mercury Mystique LS 2.0 L4 GAS Wiring Diagram Components on diagram: |
1996 Mercury Mystique LS 2.5 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1996 Mercury Mystique AUTOMOBILES
OEM TSB listings for most 1996 Mercury Mystique cars and light trucks sold in the U.S. from 1985+.
Document: RECALL - CERTAIN 1992-2003 MODEL YEAR CARS AND TRUCKS - FUSED JUMPER HARNESS REPLACEMENT FOR VEHICLES SERVICED WITH AN INCOMPATIBLE FUSED JUMPER HARNESS Vehicle: 1996 Mercury Mystique GS 2.0 L4 GAS Auto Systems: |
Document: RECALL - 1992-2004 MULTIPLE VEHICLE LINES - SPEED CONTROL SYSTEM MODIFICATION Vehicle: 1996 Mercury Mystique GS 2.0 L4 GAS |
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1996 Mercury Mystique AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1996 Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1996 Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1996 Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1996 Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1996 Mercury Mystique SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1996 Mercury Mystique vehicle. |
Access the Complete guide! |