Auto Parts Search
2000 Pontiac Grand AM CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2000 Pontiac Grand AM car and truck
repair procedures including Pontiac engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Pontiac Grand AM automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
General Service Domestic Vehicles -> 1998-2000 -> Charging System -> Avenger, Sebring Coupe & Talon -> Breeze, Cirrus, Sebring Convertible & Stratus -> Caravan, Town & Country & Voyager -> Cherokee, Dakota, Full Size Pickups & Vans, Grand Cherokee & Wrangler -> Concorde, Intrepid, LHS & 300M -> DaimlerChrysler Corp. -> Ford Motor Co. -> General Motors -> Neon
Vehicle: 2000 Pontiac Grand AM 3.4 V6 GAS
DaimlerChrysler Corp.
Avenger, Sebring Coupe & Talon
Never use cans to charge into high pressure side of system (compressor discharge port) or into system at high temperature, as high system pressure transferred into charging may cause it to explode.
- Attach center hose from manifold gauge set to refrigerant dispensing manifold. Turn refrigerant manifold valves completely counterclockwise to open fully, remove protective caps from refrigerant manifold.
- Screw refrigerant cans into manifold. Ensure gasket is in place and in good conditio...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
Hydraulic Brake Systems -> General Motors -> Component Replacement -> Master Cylinder
Vehicle: 2000 Pontiac Grand AM 3.4 V6 GAS
Master Cylinder
- On Vibe models, remove air filer hose clamp and hose from throttle body.
- On all models, disconnect fluid level sensor retainer and electrical connector.
- Drain master cylinder reservoir brake fluid into suita...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Replacement -> Except Aveo, Chevette 1.8L Diesel, Corvette, GTO, LaCrosse, Malibu (2004-06) & Malibu Maxx, Vibe, XLR, 2004-05 Corvette & 1998-2002 Metro & Prizm
Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the v...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2000 Pontiac Grand AM 3.4 V6 GAS
- Raise and suitably support vehicle.
- Remove wheel and tire.
- Remove stabilizer shaft link.
- Remove front wheel drive shaft nut. Insert a drift or a flat-bladed tool into caliper and rotor to prevent rotor from turning.
- Disconnect outer tie rod assembly from steering knuckle.
- Separate ball joint from steering knuckle. Caution: Do not attempt to move vehicle with drive axle(s) removed from wheel bearing. Wheel(s) could fall off, dropping vehicle to ground and causing personal injury or damage to vehicle.
- Separate front wheel drive axle from front wheel drive shaft bearing using a su...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Tests -> Intermittent & Poor Connections -> Intermittent Connections -> Poor Connections
Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Refer to Figs. through for diagnostic test procedures.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
Intermittent & Poor Connections
Intermittent Connections
Most intermittent connections are caused by faulty electrical connections or wiring. Inspect for the following:
- Wiring broken inside insulation.
- Poor connection between mal...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
Alternator, Replace
Vehicle: 2000 Pontiac Grand AM 3.4 V6 GAS
- Disconnect battery ground cable.
- Remove cruise control module.
- Remove engine mount.
- Rotate serpentine drive belt tensioner in clockwise direction and remove belt using suitable 3/8 inch breaker bar.
- Disconnect alternator electrical connectors and power steering line clip.
- Remove mounting bolts, nu...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
General Motors Corp./Saturn Cars -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 1999-02 Grand Am -> Reset
Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS
Reset
The Tire Low Tire Pressure indicator will turn on when the pressure in one of the tires becomes 12 psi. lower or higher then the other three. The low tire pressure monitor system uses the ABS (Anti-Lock Brake System) wheel speed sensors to determine if a tire is low by a variation in wheel speed.
- Inflate all tires to vehicle manufacturer's specifications.
- Place the ignition switch in the on position.
- Press the RESET button l...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
Radiator, Replace
Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS
- Recover air conditioning refrigerant.
- Drain coolant into suitable container.
- Remove battery and battery tray.
- Remove upper radiator hose.
- Remove upper transaxle cooler line.
- Remove coolant surge tank hose.
- Remove condenser inlet fitting from discharge hose.
- Disconnect cooling fan electrical connector.
- Raise and support vehi...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 Pontiac Grand AM AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 Pontiac Grand AM AUTOMOBILES
Component location diagrams for most 2000 Pontiac Grand AM cars and light trucks sold in the U.S. from 1990+.
 Engine Components Diagram for 2000 Pontiac Grand AM 3.4 V6 GASComponents on diagram: |
 Luggage Compartment Components Diagram for 2000 Pontiac Grand AM 2.4 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 Pontiac Grand AM AUTOMOBILES
OEM drawn wiring diagrams for most 2000 Pontiac Grand AM cars and light trucks sold in the U.S.
 2000 Pontiac Grand AM 2.4 L4 GAS Wiring DiagramComponents on diagram: |
 2000 Pontiac Grand AM 2.4 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 Pontiac Grand AM AUTOMOBILES
OEM TSB listings for most 2000 Pontiac Grand AM cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS Auto Systems: |
|
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2000 Pontiac Grand AM 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 Pontiac Grand AM AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 Pontiac Grand AM SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2000 Pontiac Grand AM vehicle.
|
| Access the Complete guide! |
