Auto Parts Search
2001 Chevrolet Tracker CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2001 Chevrolet Tracker car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chevrolet Tracker automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 2001 Chevrolet Tracker 1.6 L4 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
Power Brake Units -> Tracker Brake Booster -> Description
Vehicle: 2001 Chevrolet Tracker 2.0 L4 GAS
Vacuum assist units are similar in operation, using vacuum applied to a diaphragm or piston in opposition to atmospheric pressure in order to increase the force applied to the master cylinder piston. However, two types of vacuum assist assemblies are used, the air suspended type and the vacuum suspended type. Air suspended units are under atmospheric pressure until the brakes are applied, then engine vacuum is admitted causing the piston or diaphragm to move and apply force to the master cyl...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Tracker
Vehicle: 2001 Chevrolet Tracker 2.5 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
CV AXLE SHAFT, Replace -> Left -> Right
Vehicle: 2001 Chevrolet Tracker 2.0 L4 GAS
Left
- Raise and support vehicle.
- Remove skid plate bolts and skid plate, if equipped.
- Remove front tire and wheel assembly.
- Remove the six hub flange bolts and flange.
- Remove drive axle shaft snap ring.
- Remove drive axle shaft spindle washer from drive axle shaft.
- Use a hydraulic jack in order to support the front control arm. To prevent personal injury and/or component damage, use the proper tools to support the lower control arm when removing the coil spring. The coil spring is under extreme pressure and can become a projectile should the spring separate from the lower control ...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
Starter, Replace
Vehicle: 2001 Chevrolet Tracker 2.0 L4 GAS
- Disconnect battery ground cable.
- Remove mounting nut and battery cable from starter solenoid.
- Remove starter solenoid electrical connector.
- Remove upper mounting nut, bolt and battery cable from starter motor.
- Rem...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
General Motors Corp./Saturn Trucks -> Check Engine/Service Engine Soon Indicator Lamp -> Tracker -> California Models -> Federal Models
Vehicle: 2001 Chevrolet Tracker 2.5 V6 GAS
Federal Models
The Check Engine/Service Engine Soon lamp should light when the ignition is On with engine not operating. When engine is started, the lamp should go off. If lamp remains on, either a service interval is indicated or a code has been stored by the Electronic Control Module (ECM) memory.
At mileage intervals of 50,000, 80,000 and 100,000 miles, the Check Engine lamp should light indicating required service and maintenance is to be performed. After performing the required service, the lamp may be turned off by resetting the cancel switch located on the instrument panel.
If a ser...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
Radiator, Replace
Vehicle: 2001 Chevrolet Tracker 2.5 V6 GAS
- Remove radiator pressure cap.
- Raise and support vehicle.
- Drain engine coolant into suitable container then remove and plug transmission fluid cooler hoses from radiator.
- Remove lower shroud bolts and lower radiator outlet hose.
- Lower vehicle.
- On models equipped with air conditioning, remove mounting bolts and position air co...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Chevrolet Tracker AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2001 Chevrolet Tracker 2.0 L4 GAS
- Disconnect the negative battery cable.
- Loosen the adjusting bolt and the pivot bolt, for cooling fan.
- Remove the tension on the fan belt by rotating the tension bolt counterclockwise.
- Remove the four fan nuts. Use a second wrench to hold the fan shaft. Do not damage the rad...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Chevrolet Tracker AUTOMOBILES
Component location diagrams for most 2001 Chevrolet Tracker cars and light trucks sold in the U.S. from 1990+.
 Center Console Diagram for 2001 Chevrolet Tracker 2.5 V6 GASComponents on diagram: |
 Door Wiring Harness Diagram for 2001 Chevrolet Tracker 2.5 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Chevrolet Tracker AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Chevrolet Tracker cars and light trucks sold in the U.S.
 2001 Chevrolet Tracker 2.5 V6 GAS Wiring DiagramComponents on diagram: |
 2001 Chevrolet Tracker 2.5 V6 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Chevrolet Tracker AUTOMOBILES
OEM TSB listings for most 2001 Chevrolet Tracker cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2001 Chevrolet Tracker 2.0 L4 GAS Auto Systems: |
|
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2001 Chevrolet Tracker 2.0 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Chevrolet Tracker AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Chevrolet Tracker cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Chevrolet Tracker cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Chevrolet Tracker cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Chevrolet Tracker cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Tracker SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2001 Chevrolet Tracker vehicle.
|
| Access the Complete guide! |
