Auto Parts Search
2001 Dodge Durango CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
Component Replacement & Adjustment -> Cherokee, Dakota, Durango, Full Size Pickup, Full Size Van, Grand Cherokee, Liberty & Wrangler -> Thermostat, Replace -> 2.5L Engine -> 3.9L, 5.2L & 5.9L Engines -> 4.0L Engine -> 4.7L Engine -> 5.2L & 5.9L Engines -> 5.9L Diesel Engine -> 8.0L Engine -> Cherokee & Wrangler -> Dakota -> Except 8.0L Engine -> Full Size Pickups & Full Size Vans -> Grand Cherokee -> Liberty
Vehicle: 2001 Dodge Durango 5.9 V8 GAS
Cherokee & Wrangler
- Drain coolant from radiator until level is below thermostat housing.
- Remove upper radiator hose, then heater hose at thermostat housing and engine coolant sensor wire.
- Remove thermostat housing bolts and gasket, then the thermostat.
- Reverse procedure to install, noting the following:
- Ensure pellet encircled by coil spring faces engine.
- Ensure thermostat is in recess groove and position thermostat in groove with arrow and air bleed hole on outer flange pointing up.
- Install new gasket and torque thermosta...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
Disc Brakes -> Dakota & Durango -> Precautions -> Brake Bleed -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> Caliper Inspection -> General Precautions
Vehicle: 2001 Dodge Durango 5.9 V8 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings. The wheel bearings should be inspected at this time and repacked if necessary.
Do not get any oil or grease on the linings. It is recommended that both front wheel sets be replaced whenever a respective pad is worn or damaged. Inspect and, if necessary, replace rear brake linings also.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness o...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
DaimlerChrysler Corp./Jeep Light Trucks, SUVs & Vans -> Component Locations -> 2005-06 Liberty w/2.4L & 3.7L Engines, 2005-06 Grand Cherokee, 1998-06 Durango, 1994-06 Dakota (Except 1994 2.5L), Ram Truck 1500-3500, Ram Van 1500-3500
Vehicle: 2001 Dodge Durango 4.7 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2001 Dodge Durango 4.7 V8 GAS
Front
- With vehicle in neutral, position vehicle on hoist.
- Remove skid plate, if equipped.
- Mark a reference line across propeller shaft flange and pinion flange.
- Remove exhaust crossover bolts from exhaust manifolds and lower crossover.
- Remove boot clamp from CV joint.
- Remove pinion flange bolts.
- Slide propeller shaft off transfer case and remove shaft.
- Reverse procedure to install, noting the following:
- Align reference marks.
- Replace old pinion flange bolts with new bolts and coat with Loctite 242 threadlocker.
- Torque pinion flange bolts to 65 ft. lbs.
Rear
- With vehicle in neutral, posit...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
Starter, Replace
Vehicle: 2001 Dodge Durango 4.7 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove heat shield clip and heat shield from starter.
- Remove starter motor attaching bolts and nuts.
- Remove soleno...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
Chrysler LLC Trucks -> Anti-Lock Brake System Warning Lamp -> Chrysler, Dodge & Plymouth
Vehicle: 2001 Dodge Durango 5.9 V8 GAS
The amber lamp monitors anti-lock brake system condition. The lamp should be on during engine starting, but should go off when the self-diagnostic system determines proper system operation. If the lamp remains On, a fault in the anti-lock brake system is indicated. After diagnosis and re...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2001 Dodge Durango 4.7 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater core inlet hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at heater core.
- Disconnect heater outlet hose from heate...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Dodge Durango AUTOMOBILES
Serpentine Drive Belt, Replace -> Installation -> Removal
Vehicle: 2001 Dodge Durango 5.9 V8 GAS
Removal
The automatic tensioner is equipped with an indexing arrow on the back of tensioner housing. If a new belt is being installed, arrow must be within approximately 1/8 inch of indexing mark. If an old belt is being used, it must not pass the indexing point.
- Attach a suitable wrench to automatic tensioner pulley mounting bolt.
- Rotate tensioner assembly clockwise until tension has been relieved.
- Remove belt from idler puller...
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Dodge Durango AUTOMOBILES
Component location diagrams for most 2001 Dodge Durango cars and light trucks sold in the U.S. from 1990+.
Engine Component Locations Diagram for 2001 Dodge Durango 5.9 V8 GAS Components on diagram: |
Door Connector & Ground Locations Diagram for 2001 Dodge Durango 4.7 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Dodge Durango AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Dodge Durango cars and light trucks sold in the U.S.
2001 Dodge Durango 4.7 V8 GAS Wiring Diagram Components on diagram: |
2001 Dodge Durango 4.7 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Dodge Durango AUTOMOBILES
OEM TSB listings for most 2001 Dodge Durango cars and light trucks sold in the U.S. from 1985+.
Document: AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE - REVISED Vehicle: 2001 Dodge Durango 5.9 V8 GAS Auto Systems: |
Document: SAFETY RECALL G28 - IGNITION / PARK INTERLOCK Vehicle: 2001 Dodge Durango 5.9 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Dodge Durango AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Dodge Durango cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Dodge Durango cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Dodge Durango cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Dodge Durango cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Dodge Durango SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2001 Dodge Durango vehicle. |
Access the Complete guide! |