Auto Parts Search
2001 Ford Escort CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2001 Ford Escort car and truck
repair procedures including Ford engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Ford Escort automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Compressor Service -> Shaft Seal, Replace -> FS-10 -> Installation -> Removal
Vehicle: 2001 Ford Escort 2.0 L4 GAS
FS-10
Removal
- Clamp compressor in suitable support, then remove clutch hub as outlined under "Clutch Hub & Pulley, Replace."
- Remove shaft seal felt from nose of compressor.
- Remove snap ring as follows:
- Insert tip of snap ring remover tool No. T89P-19623-DH, or equivalent, into one eye of the snap ring, Fig. .
- Rotate snap ring until eye is close to compressor shaft, Fig. .
- Keeping tool shaft against side of nose opening, quickly pull upward and remove snap ring, Fig. .
- Push shaft seal remover over compress...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Hydraulic Brake Systems -> Hydraulic Brake System Flush
Vehicle: 2001 Ford Escort 2.0 L4 GAS
Whenever new brake components are installed in the hydraulic system, it is recommended that the entire hydraulic system be thoroughly flushed with clean brake fluid.
It may sometime become required to flush out the system due to the presence of mineral oil, kerosene, gasoline, etc., which will cause swelling of rubber piston cups and valves and render them inoperative.
Flushing is performed at e...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Ford Motor Co. Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1998-03 Escort, ZX2, LN7, Lynx & Tracer -> Normal Service -> Severe Service
Vehicle: 2001 Ford Escort 2.0 L4 GAS
Normal Service
Replac...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2001 Ford Escort 2.0 L4 GAS
- Raise and support vehicle.
- Remove lug nuts and remove front tire and wheel.
- Raise staked portion of front axle wheel hub retainer using a small cape chisel.
- Remove and discard front axle wheel hub retainer.
- Remove cotter pin and tie rod end nut.
- Use a suitable tool to separate tie rod end from front wheel knuckle.
- Remove stabilizer bar link.
- Remove nut and ball joint pinch bolt.
- Pry down on front suspension lower arm separating front suspension lower arm ball joint from front wheel knuckle.
- Pull outward on front wheel knuckle then pull front wheel driveshaft and joint from front w...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Alternator, Replace
Vehicle: 2001 Ford Escort 2.0 L4 GAS
- Disconnect battery ground cable.
- Remove alternator drive belt.
- Disconnect H02 sensor harness clip from alternator bracket.
- Remove air conditioning line bracket bolt.
- Remove power steering pressure line bracket bolts.
- Remove alternator bracket bolts.
- Position alternator bracket aside
- Remove alternator mounting bolts, then position alternator aside.
- Disconnect alternator ele...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Ford Motor Co. Cars -> Air Bag Warning Lamp ->
Vehicle: 2001 Ford Escort 2.0 L4 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If the Air B...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2001 Ford Escort 2.0 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Reposition heater core inlet hose clamp at engine.
- Remove hose from engine.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at heater core.
- Disconnect heater ou...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Ford Escort AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2001 Ford Escort 2.0 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Ford Escort AUTOMOBILES
Component location diagrams for most 2001 Ford Escort cars and light trucks sold in the U.S. from 1990+.
 Body Diagram for 2001 Ford Escort 2.0 L4 GASComponents on diagram: |
 Body Diagram for 2001 Ford Escort 2.0 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Ford Escort AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Ford Escort cars and light trucks sold in the U.S.
 2001 Ford Escort 2.0 L4 GAS Wiring DiagramComponents on diagram: |
 2001 Ford Escort 2.0 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Ford Escort AUTOMOBILES
OEM TSB listings for most 2001 Ford Escort cars and light trucks sold in the U.S. from 1985+.
|
Document: RECALL - CERTAIN 1992-2003 MODEL YEAR CARS AND TRUCKS - FUSED JUMPER HARNESS REPLACEMENT FOR VEHICLES SERVICED WITH AN INCOMPATIBLE FUSED JUMPER HARNESS Vehicle: 2001 Ford Escort 2.0 L4 GAS Auto Systems: |
|
Document: RECALL - 1992-2004 MULTIPLE VEHICLE LINES - SPEED CONTROL SYSTEM MODIFICATION Vehicle: 2001 Ford Escort 2.0 L4 GAS |
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Ford Escort AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Ford Escort cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Ford Escort cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Ford Escort cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Ford Escort cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Ford Escort SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
