Auto Parts Search
2002 Cadillac Escalade CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Cadillac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Cadillac Escalade car and truck
repair procedures including Cadillac engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Cadillac Escalade automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
Component Replacement & Adjustment -> Light Duty Trucks & Vans -> Blower Motor, Replace -> Astro & Safari -> Aztek & Rendezvous -> Bravada, S & T Series -> C & K Series -> Front -> G Series -> Montana, Silhouette & Venture -> Rear -> Tracker -> Vue
Vehicle: 2002 Cadillac Escalade 6.0 V8 GAS
Astro & Safari
Front
- Remove air cleaner assembly.
- Disconnect electrical connector, then remove recovery and windshield washer fluid reservoir assembly.
- Remove two acoustic cover retaining screws in blower motor area.
- Cut acoustic cover between five clip lands, Fig. . Retain piece of acoustic cover for reassembly.
- Remove cooling tube from motor.
- Remove blower motor to case attaching screws.
- Remove blower motor from case.
- Reverse procedure install.
Rear
- Remove left quarter panel swing-out wind...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> Troubleshooting -> Brakes Grab -> Hard Pedal -> Slow Or No Release
Vehicle: 2002 Cadillac Escalade 5.3 V8 GAS
Hard Pedal
- Internal vacuum leak.
- Faulty control valve.
- Broken or damaged hydraulic brake lines.
- Collapsed or damaged vacuum hose.
- Plugged or loose vacuum fitting.
- Bad stud welds on front or rear housing on power head.
- Faulty booster diaphragm.
- Restricted air filter element.
- Worn or distorted reaction plate or levers.
- Cracked or broken pow...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 2002 Cadillac Escalade EXT 6.0 V8 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2002 Cadillac Escalade 5.3 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
Starter, Replace
Vehicle: 2002 Cadillac Escalade EXT 6.0 V8 GAS
- Remove mounting bolts and engine shield, if required.
- Remove mounting bolts and oil pan skid plate, if required.
- Remove righthand transmission cover bolt.
- Remove front axle mounting bracket nut, then position front axle mounting bracket bolt until tip is flush with support bushing. Do not remove bolt.
- Remove starter motor mounting bolts and slide starter forward until it clears transmission.
- Disconnect oil level sensor electrical connector.
- Remove starter solenoid n...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2002 Cadillac Escalade EXT 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Four Wheel Drive (4WD) System Warning Lamp ->
Vehicle: 2002 Cadillac Escalade 5.3 V8 GAS
This lamp should light for approximately 6-8 seconds when the ignition is turned On as a bulb check. If the ...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2002 Cadillac Escalade 5.3 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Remove air intake tube.
- Remove heater and surge tank hoses from mounting clip.
- Reposition heater core inlet hose clamp at water pump.
- Remove hose from water pump.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Cadillac Escalade AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Cadillac Escalade 6.0 V8 GAS
- Loosen air cleaner outlet duct clamps at these locations:
- Throttle body
- Mass airflow/intake air temperature (MAF/IAT) sensor
- Remove radiator inlet hose clip from outlet duct.
- Remove air cleaner outlet duct.
- Install a breaker bar with hex-head socket to drive belt tensioner bolt.
- Rotate drive be...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Cadillac Escalade AUTOMOBILES
Component location diagrams for most 2002 Cadillac Escalade cars and light trucks sold in the U.S. from 1990+.
 Left Side Frame Rail-Brake Components Diagram for 2002 Cadillac Escalade 6.0 V8 GASComponents on diagram: |
 A/C Compressor Clutch,Oil Level Switch,CKP Sensor and Starter Diagram for 2002 Cadillac Escalade 5.3 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Cadillac Escalade AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Cadillac Escalade cars and light trucks sold in the U.S.
 2002 Cadillac Escalade EXT 6.0 V8 GAS Wiring DiagramComponents on diagram: |
 2002 Cadillac Escalade 5.3 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Cadillac Escalade AUTOMOBILES
OEM TSB listings for most 2002 Cadillac Escalade cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2002 Cadillac Escalade 6.0 V8 GAS Auto Systems: |
|
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2002 Cadillac Escalade 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Cadillac Escalade AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Cadillac Escalade cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Cadillac Escalade cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Cadillac Escalade cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Cadillac Escalade cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Escalade SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
