Auto Parts Search
2002 Chevrolet Tahoe CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Chevrolet Tahoe car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chevrolet Tahoe automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
Compressor Service -> HD6/HT6/HU6 Compressor -> Compressor Clutch Service -> Clutch Coil, Replace -> Clutch Plate & Hub, Replace -> Clutch Pulley & Bearing, Replace -> Installation -> Removal
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 FLEX
Clutch Plate & Hub, Replace
Service procedures given are for compressor removed and mounted in suitable holding fixture. However, on most applications, compressor clutch components can be serviced without removing compressor or recovering refrigerant from system. If refrigerant recovery becomes necessary, refer to for procedure.
To prevent serious internal compressor damage, when removing or installing clutch components, never apply pressure directly to the compressor shaft. Always use a suitable shaft protector.
Removal
Refer to Fig. when performing compressor and clutc...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
Anti-Lock Brakes -> Kelsey-Hayes -> Diagnosis & Testing -> 2002 -> 2002-03 -> 2003-06 -> 2004-06 -> Accessing Diagnostic Trouble Codes -> Astro, Blazer, Jimmy, Safari, Sonoma, SSR & S10 -> Avalanche, Escalade, Escalade EXT, Suburban, Tahoe & Yukon -> Bravada, Envoy, Rainier & Trailblazer -> Clearing Diagnostic Trouble Codes -> Connector Pin Identification -> Diagnostic Tests -> Diagnostic Trouble Code Interpretation -> Express & Savana -> Intermittents & Poor Connections -> Sierra & Silverado -> Symptom Tests -> Temperature Vs. Resistance
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to Data Link Connector (DLC) and follow manufacturers instructions.
Diagnostic Trouble Code Interpretation
Astro, Blazer, Jimmy, Safari, Sonoma, SSR & S10
[[table data]]Avalanche, Escalade, Escalade EXT, Suburban, Tahoe & Yukon
2002
[[table data]]2003-06
[[table data]]Bravada, Envoy, Rainier & Trailblazer
2002-03
[[table data]]2004-06
[[table data]]Express & Savana
2002
[[table data]]2003-06
[[table data]]Sierra & Silverado
2002
[[table data]]2003-06
[[table data]]Connector Pin Identification
[[table data]]Diagnostic Tests
Astro, Blazer, Jimmy, Safari, Sonoma, SSR & S10
[[table data]]Avalanche, Escalade, Escalade EXT, Suburban, Tahoe & Yukon
2002
[[table data]]2003-06
[[table data]]Bravada, Envoy, Rai...
[[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]]CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Scheduled Maintenance -> 1996-03 C/K, G & R/V Series w/Gasoline Engine -> Heavy Duty Emissions -> Light Duty Emissions -> Normal Service -> Severe Service
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 GAS
Light Duty Emissions
Normal Service
Replace every 30,000 miles
Severe Service
Rep...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2002 Chevrolet Tahoe 4.8 V8 GAS
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Remove drive axle center cap, if equipped.
- Insert a drift or large screwdriver through brake caliper into one of the brake rotor vanes in order to prevent drive axle wheel drive shaft from turning.
- Remove nut and washer from hub. Do not reuse nut. A new nut must be used when installing wheel drive shaft.
- Using J 45859 or equivalent, press wheel drive shaft from hub.
- Remove bolts securing wheel drive shaft ...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
Alternator, Replace
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 FLEX
- Disconnect battery ground cable.
- Remove air inlet duct, if required.
- Disconnect terminal plug and battery lead connections from back of alternator.
- Remove upper fan shroud mounting bolts and fan shroud.
- Remove accessory drive belt using suitable 3/8 i...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 FLEX
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
General Motors Corp./Saturn Trucks -> Traction Control System (TCS)/Electronic Stability Control (ESC) Warning Lamp ->
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If t...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
Radiator, Replace
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 GAS
- Drain radiator coolant into suitable container.
- Remove upper and lower radiator hoses.
- Remove mounting bolts and lower fan shroud.
- Remove engine vent hose and surge take hose.
- Disconnect eng...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Chevrolet Tahoe AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Chevrolet Tahoe 5.3 V8 FLEX
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Chevrolet Tahoe AUTOMOBILES
Component location diagrams for most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S. from 1990+.
 Radiator Support Diagram for 2002 Chevrolet Tahoe 4.8 V8 GASComponents on diagram: |
 Electronic Traction Control Switch Diagram for 2002 Chevrolet Tahoe 5.3 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Chevrolet Tahoe AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S.
 2002 Chevrolet Tahoe 5.3 V8 FLEX Wiring DiagramComponents on diagram: |
 2002 Chevrolet Tahoe 5.3 V8 FLEX Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Chevrolet Tahoe AUTOMOBILES
OEM TSB listings for most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2002 Chevrolet Tahoe 4.8 V8 GAS Auto Systems: |
|
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2002 Chevrolet Tahoe 4.8 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Chevrolet Tahoe AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tahoe SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2002 Chevrolet Tahoe vehicle.
|
| Access the Complete guide! |
