Auto Parts Search
2002 Honda Odyssey CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Honda REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Honda Odyssey car and truck
repair procedures including Honda engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Honda Odyssey automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Honda -> Component Replacement & Adjustment -> Adjustments -> Accord -> Civic, CR-V, Prelude & S2000 -> Odyssey -> Temperature Control Cable
Vehicle: 2002 Honda Odyssey Cargo 3.5 V6 GAS
Refer to the "Rodeo" for "Honda Passport" information.
Temperature Control Cable
Accord
- Open clamp and disconnect heater valve cable from arm, Figs. and .
- Disconnect clamp and cable from air mix control linkage, Fig. .
- Set temperature control dial on MAX COOL with ignition switch in On position.
- Attach cable to air mix control linkage.
- Hold cable housing against stop and cap housing into cable clamp.
- Turn heater valve arm to fully closed position and hold.
- Take up cable housing by pulling cable housing, then install i...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Disc Brakes -> Caliper Service -> Assemble -> Disassemble -> Front -> Overhaul -> Rear -> Replace
Vehicle: 2002 Honda Odyssey Cargo 3.5 V6 GAS
Front
Replace
Ensure dirt or other foreign matter is not allowed to contaminate brake fluid. Do not mix different types of brake fluid, as they might not be compatible.
- Refer to Figs. through when replacing calipers.
- Raise and support front of vehicle, then remove wheel and tire assemblies.
- Remove banjo bolt and disconnect brake hose from caliper.
- Remove caliper bolts, then the caliper.
- Reverse procedure to install.
Overhaul
Disassemble
- Refer toFigs. through when overhauling calipers.
- Remove caliper assembly from vehicle as outlined under " Brake Pad Service."
- Remove pad spring from calip...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Honda -> Fuel Filter Replacement -> 1999-04 Odyssey -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2002 Honda Odyssey Cargo 3.5 V6 GAS
Fuel System Pressure Relief
- Obtain the vehicle owners radio theft protection code prior to disconnecting the battery ground cable, if equipped.
- Disconnect the battery ground cable.
- Remove the fuel fill cap to release fuel tank pressure.
- Place a shop towel over the fuel pulsation damper located on top of fuel r...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
CV AXLE SHAFT, Replace -> Front
Vehicle: 2002 Honda Odyssey LX 3.5 V6 GAS
Front
- Loosen wheel nuts slightly.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Lift up locking tab on spindle nut then remove nut.
- Drain transmission fluid, then reinstall drain plug using new washer.
- Remove lock pin from lower arm ball joint castle nut and remove nut then separate lower ball joint lower arm from using ball joint thread protector and remover.
- To avoid damaging ball joint, install ball joint thread protector onto threads of ball joint stud. Be careful not to damage ball joint boot when instal...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Alternator, Replace
Vehicle: 2002 Honda Odyssey Cargo 3.5 V6 GAS
- Make sure you have anti-theft codes for radio and navigation system, then write down customer's audio presets. Make sure ignition switch is OFF.
- Disconnect battery ground cable, then disconnect positive cable at battery.
- Remove intake manifold cover.
- Remove drive belt.
- Remove harness clamp, then remove bracket.
- Disconnect alternator connector and black wire from alternator.
- Remove bolt, then disconnect A...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Cabin Air Filter Service -> Honda -> 1998-2004 Odyssey & 2003-08 Pilot
Vehicle: 2002 Honda Odyssey LX 3.5 V6 GAS
On 1998-2004 Odyssey models, the cabin air filter should be replaced every 30,000 miles or 24 months. If the vehicle is operated primarily in urban areas with high concentrations of soot and diesel powered vehicles, replace the filter every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
On 2003-05 Pilot models, the cabin air filter should be replaced every 30,000 miles or 24 months. The filter should be replaced more often if air flow is less than normal.
On 2006-08 Pilot models, the cabin air filter should be replaced at ...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Honda -> Anti-Lock Brake System (ABS)/VSA System Warning Lamp -> 1999-2005 Odyssey
Vehicle: 2002 Honda Odyssey EX 3.5 V6 GAS
The Anti-Lock warning lamp is used to warn of a system fault. The lamp monitors the condition of the anti-lock brake system. It will be lit during engine start-up, but should go off when the self-diagnostic system determines that the system is operating properly. If the lamp remains lit, a fault in the anti-lock brake system is indicated. After diagnosis and repair of the system, clear the ABS DTCs as follows:
- Place ignition switch in the Off position.
- Connect the Honda PGM Tester, or equivalent suitable scan tool, to the DLC connector located behind the driver's kick panel.
- Sele...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Radiator, Replace
Vehicle: 2002 Honda Odyssey LX 3.5 V6 GAS
- Drain engine coolant into suitable container.
- Remove radiator cover.
- Remove harness clamp, then the mounting bolts and bulkhead bracket,
- Remove battery, then the engine wire harness connectors from battery base.
- Remove ground cable and relay box bracket.
- Remove mounting bolts and battery base.
- Remove harness clamps, then the fan motor and air ...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Honda Odyssey AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Honda Odyssey Cargo 3.5 V6 GAS
- Rotate or lift belt tensioner arm, using a suitable wrench to relieve tension from drive belt. This is a hydraulic type a...
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Honda Odyssey AUTOMOBILES
Component location diagrams for most 2002 Honda Odyssey cars and light trucks sold in the U.S. from 1990+.
 Safety Indicator System Components Diagram for 2002 Honda Odyssey EX 3.5 V6 GASComponents on diagram: |
 Under Driver's Seat Diagram for 2002 Honda Odyssey Cargo 3.5 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Honda Odyssey AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Honda Odyssey cars and light trucks sold in the U.S.
 2002 Honda Odyssey LX 3.5 V6 GAS Wiring DiagramComponents on diagram: |
 2002 Honda Odyssey EX 3.5 V6 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Honda Odyssey AUTOMOBILES
OEM TSB listings for most 2002 Honda Odyssey cars and light trucks sold in the U.S. from 1985+.
|
Document: ATEQ VT55 TPMS Update Information Vehicle: 2002 Honda Odyssey EX 3.5 V6 GAS Auto Systems: |
|
Document: ED-18 Battery Analyzer Update Information Vehicle: 2002 Honda Odyssey EX 3.5 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Honda Odyssey AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Honda Odyssey cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Honda Odyssey cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Honda Odyssey cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Honda Odyssey cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Honda Odyssey SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
