Auto Parts Search
2002 MERCEDES-BENZ SLK32 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT MERCEDES-BENZ REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 MERCEDES-BENZ SLK32 car and truck
repair procedures including MERCEDES-BENZ engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your MERCEDES-BENZ SLK32 automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Air Bag System Precautions -> Mercedes-Benz -> Disarming
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
When the battery is disconnected, the vehicle electronic memory will be lost. Make note of radio stations and other codes. Never use a back-up power source to retain memory.
- Obtain radio theft protection CODE card.
- Turn ignition switch to OFF position and remove key.
- D...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Hydraulic Brake Systems -> Brake System Bleed -> Less ESP -> With ESP
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
Less ESP
- Connect suitable brake fluid changing tool following tool manufacturer's instructions. Bleed pressure is 29 psi.
- Open righthand rear brake caliper bleed screw and allow approximately 2.7 ounces of brake fluid to flow out without any bubbles.
- Tighten bleed screw to specifications.
- Repeat bleeding procedure at lefthand rear, righthand front and lefthand front calipers.
- On CL55, CL500, CL600, S55, S430, S500 and S600 models, open master cylinder bleed screw and allow brake fluid to flow without any bubbles. Tighten bleed screw to specifications.
- On all models, operate brake p...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Mercedes-Benz -> Fuel Filter Scheduled Maintenance -> 1980-02 Models w/Gasoline Engines -> Normal Service -> Severe Service
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
Normal Service
Replace e...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
- Remove lefthand frame cross brace, Fig. .
- Disconnect exhaust system suspension rubbers and support at rear muffler.
- Disconnect exhaust shield from tunnel.
- Remove rear transverse bridge and reinforcement brace.
- Loosen clamping nut.
- Loosen intermediate bearing mounting bolts.
- Remove rear engine mount.
- Remove mounting bolts and nuts, then disconnect front propeller shaft from transmission. Flexible disc remains on propeller shaft.
- Remove mounting bolts and nuts, then disconnect rear propeller shaft from differential carrier. Flexible disc remains on propeller shaft.
- Loosen flexible disc...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Starter, Replace
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
- Disconnect electrical connectors.
- Remove mounting bolts, then the cable and hose brackets...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Cabin Air Filter Service -> Mercedes-Benz -> 2002-04 SLK Class
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the instrument panel righthand lower trim panel.
- Slide the three cabin air filter cover retainers securing the cover to the bottom of the AC/heate...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Mercedes-Benz -> Flexible Service System (FSS) -> 1998-2002 All & 2003-09 ML Class & SLK Class
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
The Flexible Service System (FSS), permits a flexible service schedule which is related to the operating conditions of the vehicle. Depending upon vehicle operating conditions, the miles or days remaining until the next service interval are calculated and will appear in the display panel below the speedometer for 10 seconds when the FSS (1 or 0) button is depressed twice,Figs. through . On models equipped with multi-function display, use steering wheel multifunction button to access the FSS display, Fig. . On all models, the miles or days ...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Radiator, Replace
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
- Remove engine compartment panel.
- Drain radiator coolant into suitable container.
- Disconnect fan connector and remove shroud.
- Remove radiator bottom ATF line fixture mounting bolt.
- Disconnect ATF lines from radiator. Plug and seal lines and...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS
- Open engine hood.
- Rotate belt tensioner pulley counterclockwise, using a suitable tool to relieve tension from drive belt.
- Lock tensio...
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
Component location diagrams for most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S. from 1990+.
 Left Rear Wheel Hub Diagram for 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GASComponents on diagram: |
 Center Console, Rearwards Of Shifter Lever Diagram for 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
OEM drawn wiring diagrams for most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S.
 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS Wiring DiagramComponents on diagram: |
 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
OEM TSB listings for most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S. from 1985+.
|
Document: Maintenance Systems Overview Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS Auto Systems: |
|
Document: Introduction of Improved Single-Component Windshield/Window Bonding System Vehicle: 2002 MERCEDES-BENZ SLK32 AMG 3.2 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 MERCEDES-BENZ SLK32 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 MERCEDES-BENZ SLK32 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 MERCEDES-BENZ SLK32 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2002 MERCEDES-BENZ SLK32 vehicle.
|
| Access the Complete guide! |
