Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Toyota Corolla car and truck
repair procedures including Toyota engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 2002 Toyota Corolla automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 2002 Toyota Corolla AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Toyota Corolla cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Service -> Assemble -> Disassemble -> Except Sienna -> Inspection -> Master Cylinder -> Overhaul -> Sienna -> Wheel Cylinders
Vehicle: 2002 Toyota Corolla 1.8 L4 GAS
Master Cylinder
Except Sienna
Disassemble
For the following procedures, refer to Fig. for assistance.
- Remove master cylinder boot.
- Remove setscrew and reservoir tank, then the cap and strainer from reservoir.
- Remove two grommets and place cylinder in vise.
- Push piston in and remove stopper bolt, Fig. .
- Push pistons in and remove snap ring, then No. 1 piston carefully by hand.
- Place cylinder on edges of two wooden blocks and tap on cylinder until No. 2 piston comes out.
Inspection
Clean parts with compressed air. Inspect cylinder bore for rust and scoring. Also, inspect for wear or damag...
CLICK HERE TO GET FULL ACCESS TO 2002 Toyota Corolla BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Toyota Corolla AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Toyota Corolla cars and light trucks from 1990+.
Hydraulic Brake Systems -> Brake System Bleed -> Brake Lines -> Master Cylinder
Vehicle: 2002 Toyota Corolla 1.8 L4 GAS
Master Cylinder
- Fill reservoir with fluid.
- Disconnect tubes from master cylinder. Then slowly depress brake pedal and hold.
- Block off outlet holes with fingers, and release pedal. Repeat three or four times.
Brake Lines
Bleed wheel with longest brake line first, then work your way...
CLICK HERE TO GET FULL ACCESS TO 2002 Toyota Corolla BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Toyota Corolla AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Toyota Corolla cars and light trucks from 1990+.
Anti-lock Brakes -> Precautions -> Audio Coded Anti-Theft System -> Battery Ground Cable
Vehicle: 2002 Toyota Corolla 1.8 L4 GAS
Audio Coded Anti-Theft System
Some models are equipped with an audio coded anti-theft system that will disable the radio when the battery cable is disconnected. The system can be identified by the "ANTI-THEFT SYSTEM" on the cassette lid. Obtain 3 digit code for input. Reset system after service as follows:
- Obtain 3 digit audio theft code.
- Depress 1 (PROG) while depressing righthand side of TUNE SEEK button,- - - will appear in tape operation display.
- To enter the first digit, depress 1 (PROG) button repeatedly until the number of times depressed equals the first digit (depress the 1 butto...
CLICK HERE TO GET FULL ACCESS TO 2002 Toyota Corolla BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Toyota Corolla AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Toyota Corolla cars and light trucks from 1990+.
Anti-lock Brakes -> Troubleshooting
Vehicle: 2002 Toyota Corolla 1.8 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 2002 Toyota Corolla BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Toyota Corolla AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Toyota Corolla cars and light trucks from 1990+.
Disc Brakes -> Front Disc Brakes -> Brake Pad Service -> 2WD -> 4Runner -> 4WD -> Avalon, Camry, Camry Solara, Corolla, Celica, Highlander, MR2 & Sienna -> Disc, Replace -> Echo & RAV4 -> Land Cruiser -> Sequoia & Tundra -> Supra -> T100 -> Tacoma -> Tercel
Vehicle: 2002 Toyota Corolla 1.8 L4 GAS
Avalon, Camry, Camry Solara, Corolla, Celica, Highlander, MR2 & Sienna
- Remove front wheel and reinstall lug nuts to locate disc temporarily.
- Remove caliper from torque plate and suspend so brake hose is not under tension. Do not disconnect brake hose.
- Refer to Figs. through and remove the following components:
- Brake pads.
- Anti-squeal shims.
- Pad wear indicator plates.
- Support plates.
- Anti-squeal springs.
- Install new pad support plates.
- Install new pad wear indicator plates on each pad with arrow pointing in direction of disc rotation.
- Install new anti-squeal shims on each pad.
- Install ea...
CLICK HERE TO GET FULL ACCESS TO 2002 Toyota Corolla BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Toyota Corolla AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Toyota Corolla cars and light trucks from 1990+.
Hydraulic Brake Systems -> Tightening Specifications
Vehicle: 2002 Toyota Corolla 1.8 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 2002 Toyota Corolla BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
