Auto Parts Search
2004 Chevrolet Express 3500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2004 Chevrolet Express 3500 car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chevrolet Express 3500 automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
Computer Relearn Procedures -> General Motors Corp. -> 1997-98 -> 1998-2000 -> 1998-99 -> 1999-2001 -> 1999-2002 -> 2.2L & 2.4L Engines -> 2000-02 -> 2000-04 -> 2001-02 -> 2001-04 -> 3.1L, 3.4L, 3800/3.8L, 4.0L & 4.6L Engines -> 3.5L Engine -> 5.7L Engine -> Achieva, Alero, Grand Am & Skylark -> Achieva, Cavalier, Skylark & Sunfire -> Alero & Grand Am -> Alero & Malibu -> Aurora -> Aurora, Bonneville, DeVille, LeSabre & Seville -> Aurora, Bonneville, Grand Prix, LeSabre & Park Avenue -> Auto Learn Passlock Procedure -> Body Control Module (BCM) -> Bonneville -> Bonneville, Eighty Eight, LeSabre, LSS & Park Avenue -> C & K Series w/Diesel Engine -> C & K Trucks w/Diesel Engine -> Camaro & Firebird -> Catera -> Cavalier & Sunfire -> Century -> Century, Grand Prix, Impala, Intrigue, Lumina, Monte Carlo & Regal -> Century, Impala, Intrigue, Monte Carlo & Regal -> Corvette -> Crankshaft Position System Variation Learn -> Cutlass & Malibu -> Dash Integration Module (DIM) -> DeVille -> DeVille, Eldorado & Seville -> EEPROM -> Eldorado -> Engine Control Module (ECM) -> Engine Performance -> Except Park Avenue -> Grand Am -> Grand Prix & Regal -> Impala & Monte Carlo -> Instrument Panel Integration Module (IPM) -> Intrigue -> LeSabre -> Less Tech 2 Or Techline Terminal -> Light Truck & Vans -> Park Avenue -> Passenger Cars -> Passkey Module -> Passlock Learn Procedure -> PCM -> Powertrain Control Module (PCM) -> Powertrain Control Module (PCM) & Vehicle Control Module (VCM) -> Rear Integration Module -> Riviera -> Seville -> T50/T60/T20+ -> TDC Offset Adjustment -> Theft Deterrent System Programming -> VCM -> With Tech 2 -> With Techline Terminal & Scan Tool
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
Passenger Cars
Body Control Module (BCM)
Alero & Grand Am
This procedure must be performed if the BCM, Passlock sensor or PCM is replaced. If BCM is not properly programmed, it will not control all the features properly.
- Ensure battery is fully charged and ignition switch is in the ON position.
- Connect a suitably programmed Tech II, or equivalent, scan tool to Data Link Connector (DLC).
- Access scan tool "Special Functions" menu and follow scan tool instructions to program BCM.
- If BCM fails to accept the pr...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
Drum Brakes -> Precautions
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
When working on or around brake assemblies, care must be taken to prevent breathing asbestos dust, as many manufacturers incorporate asbestos fibers in the production of brake linings. During routine service operations, the amount of asbestos dust from brake lining wear is at a low level because of a chemical breakdown during use and a few precautions will minimize exposure. Do not sand or grind brake linings unless suitable local exhaust ventilation equipment is used to prevent excessiv...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
DRIVESHAFT, Replace -> Front -> One Piece Driveshaft -> Rear -> Two Piece Driveshaft
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
Front
- Raise and support vehicle.
- Mark the front U-joint to the pinion yoke on the front differential.
- Mark the relationship of the rear U-joint to the transfer case drive flange.
- Remove the retaining nuts and bolts from the drive flange.
- Remove the clamps and retaining bolts from the front drive axle pinion flange.
- Remove the front propeller shaft from the vehicle.
- Using tape and or a rubber band, wrap the front U-joint bearing caps to ensure the caps do not separate from the U-joint.
- Reverse procedure to install, noting the following:
- Torque front propeller shaft retainer bolts 18 f...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
Starter, Replace
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
- Raise and support vehicle.
- Remove starter to engine brace and heat shields.
- Disconnect wires from solenoids.
- Remove starter motor mounting bolts, washers and lower starter. Record position of shims, if required.
- Remove starter motor from vehicle.
- Reverse procedure to install, noting the fol...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Four Wheel Drive (4WD) System Warning Lamp ->
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
This lamp should light for approximately 6-8 seconds when the ignition is turned On as a bulb check. If the ...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
Radiator, Replace
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
- Drain cooling system into a suitable container, then disconnect hose from coolant reservoir.
- Remove coolant recovery reservoir retaining screws, then coolant recovery reservoir.
- Remove air intake duct, then disconnect mass air flow sensor electrical connector.
- Remove MAF/IAT sensor, then pull up on ai...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 Chevrolet Express 3500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 Chevrolet Express 3500 AUTOMOBILES
Component location diagrams for most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S. from 1990+.
 Ground Locations Diagram for 2004 Chevrolet Express 3500 6.0 V8 GASComponents on diagram: |
 Engine Components Diagram for 2004 Chevrolet Express 3500 6.0 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 Chevrolet Express 3500 AUTOMOBILES
OEM drawn wiring diagrams for most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S.
 2004 Chevrolet Express 3500 6.0 V8 GAS Wiring DiagramComponents on diagram: |
 2004 Chevrolet Express 3500 6.0 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 Chevrolet Express 3500 AUTOMOBILES
OEM TSB listings for most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS Auto Systems: |
|
Document: Front or Rear Axle Vent Hose Fluid Leak Vehicle: 2004 Chevrolet Express 3500 6.0 V8 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 Chevrolet Express 3500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 Chevrolet Express 3500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 Chevrolet Express 3500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2004 Chevrolet Express 3500 vehicle.
|
| Access the Complete guide! |
