Auto Parts Search
2004 MERCEDES-BENZ E55 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT MERCEDES-BENZ REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Imported Cars & Light Trucks & Vans -> 2003-04 -> Evacuating System -> Using Charging Station -> Using Vacuum Pump
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
Using Vacuum Pump
Vacuum pumps suitable for removing air and moisture from A/C systems are commercially available. A specification for system pump down used here is 28-291/2 inches vacuum. This reading can be attained at or near sea level only. For each 1000 feet of altitude this operation is performed, the reading will be 1 inch vacuum higher. For example, at 5000 feet elevation, only 23-241/2 inches of vacuum can be obtained. The system refrigerant must be completely recovered before it can be evacuated. Damage to the vacuum pump will result if pressurized ...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 A/C & HEATER SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Mercedes-Benz -> Fuel Filter Scheduled Maintenance -> 2004-06 E Series w/Gasoline Engines -> Normal Service -> Severe Service
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
Normal Service
Se...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
- Deactivate SBC brake system using STAR DIAGNOSIS.
- Empty rear air springs using STAR DIAGNOSIS.
- Remove twelve-point nut from rear axle shaft.
- Remove rear wheel.
- Remove brake pads on rear axle. Hang the floating caliper up with a hook to relieve the strain on the brake hose.
- Detach rear brake cable. Only detach in the case of an automatic cable slack adjuster.
- Detach link rod of torsion bar from wheel carrier.
- Raise wheel carrier using transmission jack and transmission platform until axle shaft is roughly horizontal.
- Detach torque strut from wheel carrier.
- Detach camber strut from ...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Component Replacement -> Control Module -> Sensor
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
Control Module
- Read out variant coding of TPMS (RDK) control module (N88). To do this connect STAR DIAGNOSIS and transfer data of TPMS (RDK) control module (N88) to STAR DIAGNOSIS.
- Move passenger seat into rearmost position.
- Remove floor mat and lift back floor covering in passenger foot well, Fig. .
- Remove impact absorber.
- Unscrew plastic nuts and remove step plate.
- Unlock electrical connector and unplug connector from TPMS (RDK) control module (N88).
- Unscrew bolt (6) and pull TPMS (RDK) control module (N88) out of retaining clamp.
- Reverse procedure to install, activate TPMS sele...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Starter, Replace
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
- Turn key in electronic ignition lock EIS to position "0".
- Remove battery ground cable from battery.
- Remove engine compartment paneling.
- Remove bolts from hydraulic line bracket.
- Reposition clamp on cable bundle.
- Remove right engine mount.
- Remo...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Cabin Air Filter Service -> Mercedes-Benz -> 2003-09 E & 2006-09 CLS Class
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
On 2003-05 models, under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
On 2006-08 models except AMG, under normal operating conditions the cabin air filter should be replaced every 24 months or 26,000 miles. In dusty areas change the cabin air filter more often.
On 2009 models except AMG, under normal operating conditions the cabin air filter should be replaced every 24 months or 20,000 miles. In dusty areas change the cabin air filter more of...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Mercedes-Benz -> Brake Assist System (BAS)/Acceleration Slip Regulation (ASR) Or Brake Assist System (BAS)/Electronic Stability Program (ESP) Warning Lamp ->
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
The Brake Assist System (BAS)/Acceleration Slip Regulation (ASR) or Brake Assist System (BAS)/Electronic Stability Program (ESP) warning lamp, will illuminate when the ignition switch is placed in the On position to indicate the warning lamp is operational. The lamp should go off when the engine is started. If the warning lamp remains on after the engine has been started or has come on while driving the vehicle, a fault in the BAS, ASR or ESP h...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Radiator, Replace
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
Risk of explosion from explosive gas. Risk of poisoning and caustic burns from swallowing battery electrolyte. Risk of injury through burns to skin and eyes from battery acid or when handling damaged lead-acid batteries. No fire, sparks, naked flames or smoking. Wear protective gloves, acid-resistant clothing and safety glasses. Pour battery electrolyte only into suitable and appropriately marked containers. Lethal injuries are possible if vehicle slips off of lifting platform Align vehicle between columns of hydraulic hoist and position four support plates below hoist support...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS
- Remove viscous fan mounting nut while counterholding pulley socket bolts with suitable wrench. Mounting nut has righthand threads.
- Disconnect fan connector and remove shroud.
- Remove fa...
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
Component location diagrams for most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S. from 1990+.
Underbody Component Locations Diagram for 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS Components on diagram: |
Trunk Compartment Component Locations Diagram for 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
OEM drawn wiring diagrams for most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S.
2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS Wiring Diagram Components on diagram: |
2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
OEM TSB listings for most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S. from 1985+.
Document: Re-code the Software Calibration Number (SCN) Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS Auto Systems: |
Document: Maintenance Systems Overview Vehicle: 2004 MERCEDES-BENZ E55 AMG 5.5 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 MERCEDES-BENZ E55 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 MERCEDES-BENZ E55 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 MERCEDES-BENZ E55 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 MERCEDES-BENZ E55 vehicle. |
Access the Complete guide! |