Auto Parts Search
2004 Nissan Titan CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Nissan REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Air Bag System Precautions -> Nissan -> Arming
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
- Ensure no one is inside vehicle.
- Connect air bag module electrical connector.
- Connect battery positive cable, then the ground cable.
- From a safe location at the sides of or below the air bag modules, turn ignition On and observe SRS ...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Nissan -> Disc Brakes -> Brake Pad Service -> Front -> Rear
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
Front
- Raise and support front of vehicle and remove wheels.
- Remove brake hose lock spring and lower pin bolt Figs. through , then pivot caliper body upwards.
- Remove pad retainers, inner and outer shims and pads.
- Install new inner pad and pivot caliper downward.
- Compress piston(s) by inserting bar through caliper opening and prying against torque member.
- Pivot caliper upw...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Nissan/Datsun -> Fuel Filter Replacement -> Titan -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
Fuel System Pressure Relief
- Remove the fuel pump fuse from the fuse panel.
- Start and run the engine until it stalls.
- After the engine stalls, crank two or three times to ensure all fuel pressure is relieved.
- Turn the ignition Off, then install the fuel pump fuse.
Removal & Installation
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental fuel spray.
After the b...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
CV AXLE SHAFT, Replace -> Front
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
Front
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Remove engine undercover bolts using suitable tool.
- Remove brake caliper torque member bolts using suitable tool. Position brake caliper aside and attach using mechanics wire.Do not press down on brake pedal while caliper is removed.
- Place alignment mark on brake disc, wheel hub and bearing assembly, then remove disc rotor.
- On models equipped with 4WD, remove cotter pin, then remove locknut from driveshaft using suitable tool.
- Remove end of driveshaft from...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Trouble Code Interpretation -> Less Scan Tool -> With Scan Tool
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
Less Scan Tool
Accessing Diagnostic Trouble Codes
To start the self-diagnostics, place the ignition switch in the On position, then ground terminal of the tire pressure warning check connector. The fault location is indicated by the blinking of the low tire pressure warning lamp, Fig. . If the low tire pressure warning lamp is blinking repeatedly at 5 Hz, there is no fault occurring in the system.
Diagnostic Trouble Code Interpretation
[[table data]]Clearing Diagnostic Trouble Codes
In order to make it easier to find the cause of hard to duplicate malfunctions, the malfunction information is s...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Starter, Replace
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
- Disconnect battery ground cable.
- Remove intake manifold.
- Disconnect starter motor electrical connectors.
- Remove starter motor mounting bolts, then the start...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Cabin Air Filter Service -> Nissan -> 2004 Titan & 2004-06 Armada
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the glove compartment lower screws, Fig. .
- Open glove compartment, then remove the four upper glove compartment screws, Fig. .
- Remove the glove compar...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Nissan -> Four Wheel Drive (4WD) Warning Lamp ->
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
When the ignition switch is placed in the on position, the 4WD warning lamp will light as a bulb check but should go off soon after the engine is started. If a malfunction in the 4WD ...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 Nissan Titan AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 Nissan Titan 5.6 V8 GAS
- Disconnect wiring harness connector from air cleaner case.
- Remove air cleaner duct and resonator assembly, then place air cleaner assembly aside.
- Rotate or lift belt te...
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 Nissan Titan AUTOMOBILES
Component location diagrams for most 2004 Nissan Titan cars and light trucks sold in the U.S. from 1990+.
CAN System (Type 14) Diagram for 2004 Nissan Titan 5.6 V8 GAS Components on diagram: |
Main Harness Diagram for 2004 Nissan Titan 5.6 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 Nissan Titan AUTOMOBILES
OEM drawn wiring diagrams for most 2004 Nissan Titan cars and light trucks sold in the U.S.
2004 Nissan Titan 5.6 V8 GAS Wiring Diagram Components on diagram: |
2004 Nissan Titan 5.6 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 Nissan Titan AUTOMOBILES
OEM TSB listings for most 2004 Nissan Titan cars and light trucks sold in the U.S. from 1985+.
Document: A/C SYSTEM O-RING SEAL LEAKS Vehicle: 2004 Nissan Titan 5.6 V8 GAS Auto Systems: |
Document: WINDSHIELD CRACKING Vehicle: 2004 Nissan Titan 5.6 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 Nissan Titan AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 Nissan Titan SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 Nissan Titan vehicle. |
Access the Complete guide! |