Auto Parts Search
2004 Toyota Matrix CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Air Bag System Precautions -> Toyota -> Disarming
Vehicle: 2004 Toyota Matrix 1.8 L4 GAS
The Supplemental Restraint System (SRS) incorporates a back up energy source that can maintain sufficient voltage to cause a deployment for up to 90 seconds after the ignition switch is turned off and the battery is disconnected.
When the battery is disconnected all vehicle memory is lost, make notes of radio station settings. Never use a back-up power source from outside the vehicle.
- Note radio station settings before disconnecting battery, as all vehicle memory will be lost.
- Place ...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Toyota -> Rear Disc & Parking Brakes -> Caliper Service -> 2003-04 -> 2005 -> Avalon -> Camry, Camry Solara & Sienna -> Celica, Corolla & MR2 -> Highlander & RAV4 -> Land Cruiser, Sequoia & 4Runner -> Matrix -> Overhaul -> Replace
Vehicle: 2004 Toyota Matrix XRS 1.8 L4 GAS
Avalon
2003-04
Replace
- Raise and support rear of vehicle, then remove tire and wheel assembly.
- Disconnect brake hose from brake tube and caliper using a suitable tool.
- Remove caliper attaching bolts, then the caliper, Fig. .
- Remove anti-squeal shim(s), brake pad, anti-rattle spring, pad guide plate and pad support plate.
- Reverse procedure to install, then bleed brake system.
Overhaul
- Remove sliding bushing and boot.
- Remove main pin boot using a suitable chisel.
- Remove piston using compressed air. When using air pressure to remove caliper piston, place a shop towel over piston to prevent it...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Toyota -> Fuel Filter Replacement -> 1998-06 Corolla & Matrix -> Fuel System Pressure Relief -> Models Less Union Bolt Fuel Line Connection -> Models w/Union Bolt Fuel Line Connection -> Removal & Installation
Vehicle: 2004 Toyota Matrix 1.8 L4 GAS
Fuel System Pressure Relief
Models w/Union Bolt Fuel Line Connection
- Obtain the vehicle owners radio theft protection code prior to disconnecting the battery ground cable, if equipped.
- Disconnect the battery ground cable.
- Remove the fuel fill cap to release fuel tank pressure.
- Place a shop towel over the union bolt at top of fuel filter. Slowly loosen the union bolt allowing fuel pressure to bleed down.
- Whenever the union bolt is loosened to relieve fuel system pressure, always replace the bolt gasket.
Models Less Union Bolt Fuel Line Connection
- Obtain the vehicle owners radio ...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2004 Toyota Matrix XRS 1.8 L4 GAS
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Drain transmission fluid and transfer case oil.
- Unstake drive shaft hub nut.
- With an assistant applying brakes, remove drive shaft hub nut.
- Remove nut, then disconnect stabilizer bar link fro shock absorber.
- Remove bolt and separate ABS speed sensor wire and hose from shock absorber.
- Remove bolt, then remove ABS speed sensor from steering knuckle.
- Remove cotter pin and nut, then separate tie rod end from steering knuckle, using a suitable pry tool.
- Remove bolt and nuts from lower ball joint, then separate lower control arm...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Starter, Replace
Vehicle: 2004 Toyota Matrix 1.8 L4 GAS
- Disconnect battery ground cable.
- Disconnect starter motor electrical connectors and positive battery cable.
- Remove starter motor upper and lower mounting bolts, then start...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Cabin Air Filter Service -> Toyota -> 2003-09 Matrix
Vehicle: 2004 Toyota Matrix XR 1.8 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 22,500 miles. In dusty areas change the cabin air filter every 10,000 miles.
- Open the glove compartment door.
- Remove the screw retaining the damper rod to the righthand side of the glove compartment door, then detach the damper rod.
- Push inward at each side of the glove compartment door to disengage the retainers, then lower the door.
- Through the glove compartment opening, depress the cabin air filter access cover retaining tabs, then remove the cover, Fig. .
- Remove the cabin air fil...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Toyota -> Low Coolant Lamp ->
Vehicle: 2004 Toyota Matrix XR 1.8 L4 GAS
This lamp will be illuminated when the coolant level in the radiator drops below a pre-determined point. To reset the lamp, bring the c...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2004 Toyota Matrix XR 1.8 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 Toyota Matrix AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 Toyota Matrix XRS 1.8 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 Toyota Matrix AUTOMOBILES
Component location diagrams for most 2004 Toyota Matrix cars and light trucks sold in the U.S. from 1990+.
Glass Hatch Opener System Location Diagram for 2004 Toyota Matrix XRS 1.8 L4 GAS Components on diagram: |
Supplemental Restraint System Location Diagram for 2004 Toyota Matrix XR 1.8 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 Toyota Matrix AUTOMOBILES
OEM drawn wiring diagrams for most 2004 Toyota Matrix cars and light trucks sold in the U.S.
2004 Toyota Matrix XRS 1.8 L4 GAS Wiring Diagram Components on diagram: |
2004 Toyota Matrix XR 1.8 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 Toyota Matrix AUTOMOBILES
OEM TSB listings for most 2004 Toyota Matrix cars and light trucks sold in the U.S. from 1985+.
Document: LONG TERM VEHICLE STORAGE GUIDELINES Vehicle: 2004 Toyota Matrix XRS 1.8 L4 GAS Auto Systems: |
Document: UPPER/LOWER WINDSHIELD/REAR GLASS TICK NOISE - REVISED Vehicle: 2004 Toyota Matrix XRS 1.8 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 Toyota Matrix AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 Toyota Matrix cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 Toyota Matrix cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 Toyota Matrix cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 Toyota Matrix cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 Toyota Matrix SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 Toyota Matrix vehicle. |
Access the Complete guide! |