Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2005 Chevrolet Trailblazer car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 2005 Chevrolet Trailblazer automobile. Try the Automotix DIY solution today!
We have info for following modifications of 2005 Chevrolet Trailblazer
- 2005 Chevrolet Trailblazer EXT LS 4.2 L6 GAS, CID:256, Fuel Injection, Aspiration:256, Engine VIN:, Desg:S
- 2005 Chevrolet Trailblazer EXT LS 5.3 V8 GAS, CID:323, Fuel Injection, Aspiration:323, Engine VIN:, Desg:M
- 2005 Chevrolet Trailblazer EXT LT 4.2 L6 GAS, CID:256, Fuel Injection, Aspiration:256, Engine VIN:, Desg:S
- 2005 Chevrolet Trailblazer EXT LT 5.3 V8 GAS, CID:323, Fuel Injection, Aspiration:323, Engine VIN:, Desg:M
- 2005 Chevrolet Trailblazer LS 4.2 L6 GAS, CID:256, Fuel Injection, Aspiration:256, Engine VIN:, Desg:S
- 2005 Chevrolet Trailblazer LT 4.2 L6 GAS, CID:256, Fuel Injection, Aspiration:256, Engine VIN:, Desg:S
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Trailblazer AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2005 Chevrolet Trailblazer cars and light trucks from 1990+.
Power Brake Units -> Delco Brake Booster -> Power Brake Unit, Replace -> Astro, Avalanche, Escalade EXT, Safari, Sierra, Silverado & SSR -> Aztek & Rendezvous -> Blazer, Bravada, Envoy, Jimmy, Rainier & Trailblazer -> Canyon, Colorado, Sonoma & S10 -> Equinox & Torrent -> Escalade, HHR, Suburban, Tahoe & Yukon -> Express & Savana -> Hummer H2 -> Hummer H3 -> Montana, Silhouette & Venture -> Relay, Terraza, SV6 & Uplander -> SRX -> Vue
Vehicle: 2005 Chevrolet Trailblazer EXT LS 5.3 V8 GAS
Aztek & Rendezvous
- Remove coolant reservoir, then relieve fuel system pressure as follows:
- Loosen fuel filler cap to discharge tank pressure.
- Connect fuel pressure gauge tool No. J-34730-1A, or equivalent, to fuel pressure connection. Wrap shop towel around connection while connecting fuel pressure gauge in order to avoid fuel spillage.
- Install bleed hose into an approved container and open valve in order to bleed fuel system pressure.
- Drain any fuel remaining in fuel pressure gauge into suitable container.
- Remove cruise control cable from module, then disconnect electrical ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Trailblazer AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2005 Chevrolet Trailblazer cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Replacement -> Master Cylinder
Vehicle: 2005 Chevrolet Trailblazer EXT LS 5.3 V8 GAS
Master Cylinder
- On models equipped with manual brake system,disconnect master cylinder pushrod from brake pedal.
- On all models, disconnect all wire con...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Trailblazer AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2005 Chevrolet Trailblazer cars and light trucks from 1990+.
Hydraulic Brake Systems -> Adjustments -> Height Sensing Proportioning Valve
Vehicle: 2005 Chevrolet Trailblazer EXT LT 5.3 V8 GAS
Height Sensing Proportioning Valve
The height sensing proportioning valve must be adjusted whenever the valve and/or linkage is disassembled or removed for service. In addition, adjustment should be inspected if excessive front wheel lock-up is experienced with a lower than desired brake application rate when vehicle is at or near maximum GVWR.
- Raise and support vehicle, leave wheels on and allow axle to hang freely.
- Remove lever retaining nut and disconnect lever from valve shaft, Fig. .
- Rotate valve shaft to permit installation of correct adjustment gauge, Fig. , ensure D shaped hol...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Trailblazer AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2005 Chevrolet Trailblazer cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Precautions -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General
Vehicle: 2005 Chevrolet Trailblazer LS 4.2 L6 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings.
Do not allow any oil or grease on the linings. It is recommended that linings be replaced in sets when worn or damaged.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pumping is experienced at low speeds, the disc may have excessive thickness v...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Trailblazer AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2005 Chevrolet Trailblazer cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Troubleshooting -> Brake Rattle -> Brake Roughness Or Chatter; Pedal Pumping -> Caliper Brake Fluid Leak -> Excessive Pedal Effort -> Excessive Pedal Travel -> Heavy Brake Drag -> No Braking Effect When Brake Pedal Is Depressed -> Pull, Uneven Or Grabbing Brakes -> Rear Brakes Locking On Application
Vehicle: 2005 Chevrolet Trailblazer LT 4.2 L6 GAS
Excessive Pedal Travel
- Worn brake linings.
- Disc pads knock back after cornering or rough road travel.
- Piston and linings not properly seated or positioned.
- Insufficient fluid in system.
- Loose wheel bearing adjustment.
- Damaged or worn caliper piston seal.
- Improper booster pushrod adjustment.
- Pads out of flat more than .005 inch.
- Rear brake automatic adjusters inoperative.
- Improperly ground rear brake shoes.
Brake Roughness Or Chatter; Pedal Pumping
- Excessive lateral runout of rotor.
- Rotor excessively out of parallel.
Excessive Pedal Effort
- Frozen or seized pistons.
- Brake fluid, oil or grease on ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Trailblazer AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2005 Chevrolet Trailblazer cars and light trucks from 1990+.
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Precautions -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General
Vehicle: 2005 Chevrolet Trailblazer EXT LS 4.2 L6 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings.
Do not allow any oil or grease on the linings. It is recommended that linings be replaced in sets when worn or damaged.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pumping is experienced at low speeds, the disc may have excessive thickness v...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2005 Chevrolet Trailblazer vehicle.
|
| Access the Complete guide! |
