Auto Parts Search
2005 Mitsubishi Galant CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Mitsubishi REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Mitsubushi -> Power Brake Units -> Power Brake Unit Service -> Pushrod Adjustment -> Replacement -> Service
Vehicle: 2005 Mitsubishi Galant LS 3.8 V6 GAS
Replacement
- Remove master cylinder as outlined under Component Replacement in "Hydraulic Brake Systems."
- Disconnect vacuum hose from power brake booster.
- Remove pin connecting power brake rod with pedal.
- Remo...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Mitsubishi -> Fuel Filter Replacement -> 2004-06 Galant w/Gasoline Engine -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2005 Mitsubishi Galant GTS 3.8 V6 GAS
Fuel System Pressure Relief
- Remove the rear seat.
- Remove the floor protector to disconnect fuel pump electrical connector.
- Start the engine and let run until is stalls.
- Place the ignition switch in Off position.
- Disconnect the battery ground cable.
- Connect the fuel pump electrical connector.
- Install the protector and rear seat.
Removal & Installation
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The hi...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
CV AXLE SHAFT, Replace -> Front
Vehicle: 2005 Mitsubishi Galant DE 2.4 L4 GAS
Front
Do not strike ABS rotors or outer race of driveshaft against other parts when removing or installing driveshaft. Use care not to strike pole piece at tip of front wheel speed sensor with tools when servicing vehicle.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Remove drain plug and drain transaxle fluid in suitable container.
- Remove wheel hub cotter pin, nut, and washer. Do not apply pressure to wheel bearing from vehicle weight to avoid possible damage when driveshaft nut is loosened.
- On models equi...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Starter, Replace
Vehicle: 2005 Mitsubishi Galant GTS 3.8 V6 GAS
- Disconnect battery ground cable.
- Disconnect and isolate battery ground.
- Remove engine undercovers.
- Remove starter motors in numbered sequence, Fig. .
- Reverse proce...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Cabin Air Filter Service -> Mitsubishi -> 1999-2005 Galant & 2000-05 Eclipse
Vehicle: 2005 Mitsubishi Galant LS 3.8 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 7,500 miles. In dusty areas change the cabin air filter more often.
- Remove the glove compartment.
- Through the glove compartment opening, remove the cabin air filter cover.
- Pull ...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Mitsubishi -> Active Skid Control System (ACS) Warning Lamp ->
Vehicle: 2005 Mitsubishi Galant ES 2.4 L4 GAS
The ACS warning lamp is used to warn of a system fault. It will be lit during engine start-up, but should go out when the self-diagnostic system determines that the system is functioning properly. The lamp will flash when the ASC is activated. If the...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2005 Mitsubishi Galant GTS 3.8 V6 GAS
Inlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater core.
- Remove hose from heater core.
- Reposition hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Mitsubishi Galant AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Mitsubishi Galant ES 2.4 L4 GAS
- Raise and support vehicle.
- Remove side engine under covers.
- Rotate auto-tensioner counterclockwise, using a suitable tool...
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Mitsubishi Galant AUTOMOBILES
Component location diagrams for most 2005 Mitsubishi Galant cars and light trucks sold in the U.S. from 1990+.
Rear Suspension Components Diagram for 2005 Mitsubishi Galant DE 2.4 L4 GAS Components on diagram: |
Body Component Locations Diagram for 2005 Mitsubishi Galant GTS 3.8 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Mitsubishi Galant AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Mitsubishi Galant cars and light trucks sold in the U.S.
2005 Mitsubishi Galant LS 3.8 V6 GAS Wiring Diagram Components on diagram: |
2005 Mitsubishi Galant LS 3.8 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Mitsubishi Galant AUTOMOBILES
OEM TSB listings for most 2005 Mitsubishi Galant cars and light trucks sold in the U.S. from 1985+.
Document: DOOR TRIM PANEL MAP POCKET BUZZ OR NOISE WITH AUDIO UNIT AT HIGH VOLUME OR BASS Vehicle: 2005 Mitsubishi Galant DE 2.4 L4 GAS Symptoms: |
Document: DIAGNOSTIC STEPS FOR DTC P2252 AND DTC P2253 ADDED - S/M REVISION Vehicle: 2005 Mitsubishi Galant DE 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Mitsubishi Galant AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Mitsubishi Galant cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Mitsubishi Galant cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Mitsubishi Galant cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Mitsubishi Galant cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Mitsubishi Galant SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Mitsubishi Galant vehicle. |
Access the Complete guide! |