Auto Parts Search
2005 Saab 9-7X CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Saab REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service

FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Saab 9-7X AUTOMOBILES
Saab -> Component Locations -> 9-2X & 9-7X
Vehicle: 2005 Saab 9-7X Linear 4.2 L6 GAS
The fuel filter is on the fue...
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Saab 9-7X AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2005 Saab 9-7X ARC 5.3 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Saab 9-7X AUTOMOBILES
Starter, Replace
Vehicle: 2005 Saab 9-7X ARC 5.3 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove rear steering gear crossmember mounting bolts and crossmember.
- Remove wire harness from wire harness retaining clips on transmission oil cooler line bracket.
- Remove transmission oil cooler line bracket bolt.
- Remove right transmission cover bolt.
- Remove starter bolts.
- Move starter toward front of vehicle, and remove transmission cover.
- Remove starter solenoid heat shield.
- Tilt and rotate starter in order to pass starter between transmission oil cooler lines...
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Saab 9-7X AUTOMOBILES
Saab -> Check Engine Lamp -> 2005-09 9-7x
Vehicle: 2005 Saab 9-7X Linear 4.2 L6 GAS
The Check Engine lamp will be illuminated when the ignition switch is in the on position with engine not running. When the engine is started, the lamp should go out. If the lamp remains lit, a diagnostic trouble code has been stored by the PCM. After diagnosis and repair are complete, to clear DTCs use a suitable scan tool. Follow scan tool manufacturers instruct...
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Saab 9-7X AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 Saab 9-7X Linear 4.2 L6 GAS
Lower
- Drain coolant into a suitable container.
- Reposition lower hose clamp at radiator and remove hose.
- Reposition lower hose clamp at coolant pump and remove hose.
- Remove hose from vehicle.
- Reverse procedure to ...
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Saab 9-7X AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Saab 9-7X Linear 4.2 L6 GAS
- Rotate or lift belt tensioner arm clockwise, using a suitable tool to relieve tension from dri...
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X SERPENTINE BELT SERVICE PROCEDURES
WIRING DIAGRAMS FOR 2005 Saab 9-7X AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Saab 9-7X cars and light trucks sold in the U.S.
![]() Components on diagram: |
![]() Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Saab 9-7X AUTOMOBILES
OEM TSB listings for most 2005 Saab 9-7X cars and light trucks sold in the U.S. from 1985+.
Document: Engine Rattle Noise after R And R of the Crankshaft Balancer -Inspect Bolt Torque Vehicle: 2005 Saab 9-7X Linear 4.2 L6 GAS Symptoms: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2005 Saab 9-7X ARC 5.3 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Saab 9-7X AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Saab 9-7X cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Saab 9-7X cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Saab 9-7X cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Saab 9-7X cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Saab 9-7X SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
![]() |
Access the Complete guide! |