Auto Parts Search
2005 Subaru Forester CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Subaru REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2005 Subaru Forester car and truck
repair procedures including Subaru engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Subaru Forester automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Subaru -> Hydraulic Brake Systems -> Troubleshooting
Vehicle: 2005 Subaru Forester X 2.5 H4 GAS
Refer to Fig. when trou...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Subaru -> Fuel Filter Replacement -> Except Justy w/Carbureted Engine -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2005 Subaru Forester XS 2.5 H4 GAS
Fuel System Pressure Relief
- On Impreza, SVX, 1990-94 Legacy models,fold down the rear seat back, then remove the floor mat and access hole lid.
- On 1995-00 Legacy models, remove the rear seat cushion and seat back, then the floor mat and access hole lid.
- On all models, disconnect the fuel pump relay electrical connector.
- Start the engine and operate until it stalls.
- After the engine has stalled, crank the engine for at least 5 seconds.
- Place the ignition switch in Off position.
- Disconnect the battery ground cable.
- Connect the fuel pump electrical connector.
- On...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2005 Subaru Forester XS 2.5 H4 GAS
Front
- Disconnect battery ground cable.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Unstake hub nut using suitable tool.
- Remove driveshaft locknut from front hub while depressing brake pedal. Remove wheel before loosening axle nut.
- Remove stabilizer link from front arm.
- Remove brake caliper bolts and support caliper to strut housing using mechanics wire.
- Remove disc brake rotor. If brake rotor is difficult to remove, drive 8mm bolt into threaded end of rotor, then remove the rotor. Reference mark surface of h...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Alternator, Replace
Vehicle: 2005 Subaru Forester XT 2.5 H4 GAS
- Disconnect ground cable from battery.
- Disconnect connector and terminal from alternator.
- Remove V-belt cover.
- Remov...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Cabin Air Filter Service -> Subaru -> 2003-07 Forester
Vehicle: 2005 Subaru Forester XT 2.5 H4 GAS
The cabin air filter should be replaced every 12 months or 7,500 miles.
- Remove nine the glove compartment retaining screws, the glove compartment, Fig. .
- Remove the cabin air filter cover, Fig. .
- Remove the cab...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Subaru -> Anti-Lock Brake System (ABS)/Traction Control System (TCS) Indicator -> 2005-09 Forester
Vehicle: 2005 Subaru Forester XT 2.5 H4 GAS
The Anti-Lock Brake/Traction Control System lamp will be illuminated when the ignition switch is in the On position with engine not running. When the engine is started, the lamp should ...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 Subaru Forester XT 2.5 H4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Remove hose from vehicle.
- Reverse proc...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Subaru Forester AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Subaru Forester XS 2.5 H4 GAS
- Remove drive belt cover. Wipe off any oil or water on belt and pulley.
- Loosen lockbolt on slider bolt.
- Loosen slider bolt.
- ...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Subaru Forester AUTOMOBILES
Component location diagrams for most 2005 Subaru Forester cars and light trucks sold in the U.S. from 1990+.
 Underhood Component Locations Diagram for 2005 Subaru Forester X 2.5 H4 GASComponents on diagram: |
 Electrical Components Location Diagram for 2005 Subaru Forester X 2.5 H4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Subaru Forester AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Subaru Forester cars and light trucks sold in the U.S.
 2005 Subaru Forester XT 2.5 H4 GAS Wiring DiagramComponents on diagram: |
 2005 Subaru Forester XS 2.5 H4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Subaru Forester AUTOMOBILES
OEM TSB listings for most 2005 Subaru Forester cars and light trucks sold in the U.S. from 1985+.
|
Document: EVAPORATIVE EMISSION SYSTEM DIAGNOSTIC
INFORMATION Vehicle: 2005 Subaru Forester X 2.5 H4 GAS Auto Systems: |
|
Document: Turbocharger Mesh Filter Screen Vehicle: 2005 Subaru Forester XT 2.5 H4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Subaru Forester AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Subaru Forester cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Subaru Forester cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Subaru Forester cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Subaru Forester cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Forester SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2005 Subaru Forester vehicle.
|
| Access the Complete guide! |
