Auto Parts Search
2006 Chevrolet Trailblazer CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
Disc Brakes -> Delco Single Piston Sliding Caliper -> Brake System Bleed -> Hydraulic System Flush -> Manual Bleed -> Master Cylinder Bleed -> Pressure Bleed
Vehicle: 2006 Chevrolet Trailblazer EXT LS 5.3 V8 GAS
Manual Bleed
- If vehicle is equipped with power brakes, remove vacuum reserve by applying brakes several times with engine off.
- Fill master cylinder reservoirs with suitable brake fluid. Ensure to always keep master cylinder reservoirs at least half full during entire bleeding procedure.
- If master cylinder is suspected to have air in bore, it must be bled first. To bleed master cylinder, proceed as follows:
- Disconnect forward brake pipe connection at master cylinder.
- Allow brake fluid to fill master cylinder bore until it begins to flow from forward pipe connector port.
- Connect and ...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Except Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Tracker & Uplander -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 2006 Chevrolet Trailblazer LT 5.3 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Engines Less Fuel Pressure ...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2006 Chevrolet Trailblazer EXT LS 4.2 L6 GAS
- Unlock steering column so that steering linkage is free to move.
- Raise the vehicle. Support vehicle with suitable safety stands.
- Remove front tire and wheel assemblies.
- In order to prevent drive axle from turning, insert a drift through brake caliper and into one of the rotor vanes.
- Remove axle nut and washer.
- Remove drift from brake rotor.
- Remove front brake rotors and support caliper with piece of wire in order to prevent damage to brake hose.
- Remove brackets from upper control arm holding both ABS wire and brake hose.
- Remove ABS bracket located on top of upper control arm ball...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
Relearn Procedures
Vehicle: 2006 Chevrolet Trailblazer LS 5.3 V8 GAS
- Apply the Parking brake, then place the ignition switch in the On position.
- Cycle the headlamp switch from Off to Parking Lamp position 4 times within 4 seconds.
- The horn should chirp twice and the low tire pressure warning indicator should begin to flash indicating the system is in the learn mode.
- If GM tool No. J-46079 or equivalent is available, starting with the left front tire, hold the antenna of the tool No. J-46079 near the valve stem on the wheel, then press the activate button and wait for the horn to chirp.
- If the tool is not available, starting with the left front tir...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
Alternator, Replace
Vehicle: 2006 Chevrolet Trailblazer EXT LT 5.3 V8 GAS
- Disconnect battery ground cable.
- Remove accessory drive belt.
- Disconnect alternator electrical connector, then alternator cable.
- Remove alternator mounting b...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
General Motors Corp./Saturn Trucks -> Reduce Engine Power Indicator Lamp ->
Vehicle: 2006 Chevrolet Trailblazer SS 6.0 V8 GAS
The Reduce Engine Power indicator lamp should light for a approximately 3 seconds when the ignition is turned On as a bulb check. If the warning lamp turns On during vehicle operation, a vehicl...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2006 Chevrolet Trailblazer EXT LS 4.2 L6 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from thermostat housing.
- Remove radiator outlet hose from thermostat housing and from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Chevrolet Trailblazer AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Chevrolet Trailblazer EXT LS 5.3 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Chevrolet Trailblazer AUTOMOBILES
Component location diagrams for most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S. from 1990+.
Splice Pack SP-206 Diagram for 2006 Chevrolet Trailblazer LS 4.2 L6 GAS Components on diagram: |
Global Positioning System Antenna Diagram for 2006 Chevrolet Trailblazer LT 4.2 L6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Chevrolet Trailblazer AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S.
2006 Chevrolet Trailblazer LT 5.3 V8 GAS Wiring Diagram Components on diagram: |
2006 Chevrolet Trailblazer EXT LS 5.3 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Chevrolet Trailblazer AUTOMOBILES
OEM TSB listings for most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S. from 1985+.
Document: Engine Rattle Noise after R And R of the Crankshaft Balancer -Inspect Bolt Torque Vehicle: 2006 Chevrolet Trailblazer EXT LS 4.2 L6 GAS Symptoms: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2006 Chevrolet Trailblazer EXT LS 4.2 L6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Chevrolet Trailblazer AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Chevrolet Trailblazer cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Trailblazer SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Chevrolet Trailblazer vehicle. |
Access the Complete guide! |