Auto Parts Search
2006 Dodge Magnum CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Hydraulic Brake Systems -> Hydraulic Brake Control Specifications
Vehicle: 2006 Dodge Magnum R/T 5.7 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
DaimlerChrysler/AMC/Eagle Passenger Cars -> Fuel Filter Replacement -> 300, Charger & Magnum -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2006 Dodge Magnum SE 2.7 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while it relearns its adaptive strategy.
Fuel System Pressure Relief
- Remove the fuel pump relay from the Power Distribution Center (PDC)....
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2006 Dodge Magnum SE 2.7 V6 GAS
- Raise and support vehicle, then remove tire and wheel assembly.
- Remove front caliper assembly from front steering knuckle assembly.
- Remove front braking disk (rotor) from hub, by pulling it straight off wheel mounting studs.
- Remove speed sensor cable routing bracket from strut assembly.
- Remove hub and bearing-to-stub axle retaining nut.
- Dislodge inner tripod joint from stub shaft retaining snap ring on transaxle assembly. Inner tripod joint is dislodged from stub shaft retaining snap ring, by inserting a pry bar between transaxle case and inner tripod joint and prying on tripo...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Trouble Code Identification -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Tire Pressure Sensor Check
Vehicle: 2006 Dodge Magnum SE 2.7 V6 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Trouble Code Identification
Refer to Fig. for diagnostic trouble code identification.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
Intermittent & Poor Connections
Intermittents
Most intermittents are caused by faulty electrical connections or wiring. Inspect for the following:
- Wiring broken inside insulation.
- Poor connection between m...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Alternator, Replace
Vehicle: 2006 Dodge Magnum SRT8 6.1 V8 GAS
- Disconnect battery ground cable.
- Rotate belt tensioner counterclockwise until it contacts its stop.
- Remove belt and slowly rotate tensioner into freearm position. Do not let tensioner arm snap back to freearm position.
- Raise and support vehicle.
- Drain enough coolant into suitable container to remove upper radiator hose.
- Remove righthand engine mount heat shield.
- Loosen, but do not remove, alternator support bracket retai...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2005-09 300, Magnum, 2006-09 Charger & 2008-09 Challenger
Vehicle: 2006 Dodge Magnum R/T 5.7 V8 GAS
The cabin air filter should be replaced every 12,000 miles.
- Open the hood.
- Remove the passenger side air inlet grille from the cowl panel, Fig. .
- Open the cabin air filter door.
- Remove the cabin air filter from the filter housing...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Chrysler LLC Cars -> Low Coolant Warning Lamp ->
Vehicle: 2006 Dodge Magnum R/T 5.7 V8 GAS
The Low Coolant warning lamp should light whenever coolant level in the coolant reservoir is ...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Radiator, Replace
Vehicle: 2006 Dodge Magnum SXT 3.5 V6 GAS
- Drain cooling system into suitable container.
- Remove upper radiator hose.
- Remove upper radiator closure panels.
- Disconnect cooling fan electrical connector, then remove mounting bolts and cooling fan.
- Raise and support vehicle.
- Remove lower splash shield.
- Remove lower radi...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Dodge Magnum AUTOMOBILES
Serpentine Drive Belt, Replace -> Installation -> Removal
Vehicle: 2006 Dodge Magnum SRT8 6.1 V8 GAS
Removal
- Rotate belt tensioner counterclockwise until it contacts a stop.
- Remove belt and slowly rotate tensioner into the freearm position. Do not let tensioner arm snap back to freearm position.
Installation
- Route belt around all pulleys except idler pulley.
- Rotate tensioner arm until it contacts a S...
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Dodge Magnum AUTOMOBILES
Component location diagrams for most 2006 Dodge Magnum cars and light trucks sold in the U.S. from 1990+.
Heated Seats Diagram for 2006 Dodge Magnum SXT 3.5 V6 GAS Components on diagram: |
Underhood Components Diagram for 2006 Dodge Magnum SXT 3.5 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Dodge Magnum AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Dodge Magnum cars and light trucks sold in the U.S.
2006 Dodge Magnum SE 2.7 V6 GAS Wiring Diagram Components on diagram: |
2006 Dodge Magnum R/T 5.7 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Dodge Magnum AUTOMOBILES
OEM TSB listings for most 2006 Dodge Magnum cars and light trucks sold in the U.S. from 1985+.
Document: Hard To Fill Or Fuel Nozzle Shuts Off Repeatedly Vehicle: 2006 Dodge Magnum SE 2.7 V6 GAS Auto Systems: |
Document: Chrome Clad Wheel Adapters For Proper Balancing Vehicle: 2006 Dodge Magnum SE 2.7 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Dodge Magnum AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Dodge Magnum SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Dodge Magnum vehicle. |
Access the Complete guide! |