Auto Parts Search
2006 GMC Sierra 2500 HD CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2006 GMC Sierra 2500 HD car and truck
repair procedures including GMC engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your GMC Sierra 2500 HD automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Anti-Lock Brakes -> Kelsey-Hayes -> Description
Vehicle: 2006 GMC Sierra 2500 HD WT 6.0 V8 GAS
When wheel slip is detected during a brake application, the ABS enters anti-lock mode. During anti-lock braking, hydraulic pressure in the individual wheel circuits is controlled to prevent any wheel from slipping. A separate hydraulic line and specific solenoid valves are provided for each wheel. The ABS can decrease, hold, or increase hydraulic pressure to each wheel brake. The ABS cannot, however, increase hydraulic pressure above the amount which is transmitted by the master cylinder during braking.
During anti-lock braking, a series of rapid pulsations is felt in the brake pedal...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Except Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Tracker & Uplander -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 2006 GMC Sierra 2500 HD SLE 6.0 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Engines Less Fuel Pressure ...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2006 GMC Sierra 2500 HD WT 6.6 V8 DIESEL
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Remove drive axle center cap, if equipped.
- Insert a drift or large screwdriver through brake caliper into one of the brake rotor vanes in order to prevent drive axle wheel drive shaft from turning.
- Remove nut and washer from hub. Do not reuse nut. A new nut must be used when installing wheel drive shaft.
- Using J 45859 or equivalent, press wheel drive shaft from hub.
- Remove bolts securing wheel drive shaft ...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Aids -> Diagnostic Check -> Diagnostic Tests -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Test Procedures
Vehicle: 2006 GMC Sierra 2500 HD SL 8.1 V8 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Test Procedures
Refer to Figs. through for diagnostic test procedures.
Diagnostic Check
- Check for aftermarket devices which could affect the operation of the TPMS to verify that none are installed.
- Check the easily accessible or visible system components for obvious damage or conditions which could cause the symptom.
- Ensure that the scan tool selected front and rear tire pressure parameters are correct compared to the tire...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Starter, Replace
Vehicle: 2006 GMC Sierra 2500 HD SL 6.6 V8 DIESEL
- Disconnect battery ground cable.
- Raise and support vehicle, then remove righthand front tire and wheel assembly.
- Remove righthand front fender wheelhouse inner panel.
- Remove starter motor battery positive cable, then solenoid wires.
- Remove star...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2006 GMC Sierra 2500 HD SL 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
General Motors Corp./Saturn Trucks -> Change Trans Fluid Indicator ->
Vehicle: 2006 GMC Sierra 2500 HD SLE 8.1 V8 GAS
This message will appear on the DIC (Driver Information Center) when it is time to change the transmission fluid....
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Radiator, Replace
Vehicle: 2006 GMC Sierra 2500 HD WT 6.6 V8 DIESEL
- Drain coolant into a suitable container.
- Remove radiator air upper baffle retainers, then upper air baffle, Fig. .
- Remove inlet and outlet hoses from radiator.
- Lift lower fan shroud upward to disengage from clips, then remove lower fan shroud from vehicle.
- Remove surge tank hose from radiator
- Remove and discard radiator quick connect fittings as follows:
- Pull caps back along pipe, then holding one leg o...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 GMC Sierra 2500 HD SL 6.0 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
Component location diagrams for most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S. from 1990+.
 Water In Fuel Sensor Diagram for 2006 GMC Sierra 2500 HD WT 6.6 V8 DIESELComponents on diagram: |
 Rear Wheel Position Sensor Diagram for 2006 GMC Sierra 2500 HD WT 6.6 V8 DIESELComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
OEM drawn wiring diagrams for most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S.
 2006 GMC Sierra 2500 HD SLE 8.1 V8 GAS Wiring DiagramComponents on diagram: |
 2006 GMC Sierra 2500 HD SLE 6.6 V8 DIESEL Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
OEM TSB listings for most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S. from 1985+.
|
Document: Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Design Change-New Head Gasket Part Numbers and Head Bolt Torque Specifications Vehicle: 2006 GMC Sierra 2500 HD WT 6.6 V8 DIESEL Auto Systems: |
|
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2006 GMC Sierra 2500 HD WT 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 GMC Sierra 2500 HD AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 GMC Sierra 2500 HD cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 GMC Sierra 2500 HD SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
