Auto Parts Search
2006 Toyota Yaris CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Toyota Yaris AUTOMOBILES
Toyota -> Fuel Filter Replacement -> Echo, Prius & Yaris -> Fuel System Pressure Relief -> Models Less Union Bolt Fuel Line Connection -> Models w/Union Bolt Fuel Line Connection -> Removal & Installation
Vehicle: 2006 Toyota Yaris LE 1.5 L4 GAS
Fuel System Pressure Relief
Models w/Union Bolt Fuel Line Connection
- Obtain the vehicle owners radio theft protection code prior to disconnecting the battery ground cable, if equipped.
- Disconnect the battery ground cable.
- Remove the fuel fill cap to release fuel tank pressure.
- Place a shop towel over the union bolt at top of fuel filter. Slowly loosen the union bolt allowing fuel pressure to bleed down.
- Whenever the union bolt is loosened to relieve fuel system pressure, always replace the bolt gasket.
Models Less Union Bolt Fuel Line Connection
- Obtain the vehicle owners radio theft...
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Toyota Yaris AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2006 Toyota Yaris RS 1.5 L4 GAS
- Raise and support vehicle.
- Remove engine under cover.
- Drain transmission fluid into a suitable container.
- Remove wheel lug nuts.
- Remove front axle hub nut.
- Remove bolt and separate speed sensor and flexible hose.
- Remove nut and separate stabilizer link from shock absorber.
- Remove cotter pin and castle nut from tie rod.
- Make sure upper ends of threaded section of tie rod end and SST (spacer B) are aligned.
- Separate tie rod end from front axle assembly.
- Remove clip and castle nut from lower control arm.
- Separate front lower contr...
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Toyota Yaris AUTOMOBILES
Starter, Replace
Vehicle: 2006 Toyota Yaris LE 1.5 L4 GAS
- Disconnect battery ground cable.
- Release tabs while pushing upward on flywheel housing side cover to remove side cover. Upon installation of flywheel housing side cover ensure tabs make a click sound to indicate cover is properly secured. Replace any worn or broken tabs on cover.
- Open B+ terminal cap...
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Toyota Yaris AUTOMOBILES
Toyota -> Engine Oil Reminder/Maintenance Required Lamp -> 2006-09 Yaris
Vehicle: 2006 Toyota Yaris LE 1.5 L4 GAS
- Turn the ignition switch to the On position and ensure that the display screen is in the Trip A mode.
- Turn the ignition switch to the Off position.
- While pressing the ODO/TRIP switch button, turn ignition switch On. Hold the button down through the entire reset procedure.
- The odometer indicates 000000 and then the oil replace...
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Toyota Yaris AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2006 Toyota Yaris CE 1.5 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Toyota Yaris AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Toyota Yaris LE 1.5 L4 GAS
- Remove bolts from righthand engine cover assembly, then remove cover.
- Loosen bolts from upper and lower alternator mounting bracket.
- Rotate or lift belt tensioner arm counterclockwise, using a suitable tool to relieve tension from...
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2006 Toyota Yaris AUTOMOBILES
OEM TSB listings for most 2006 Toyota Yaris cars and light trucks sold in the U.S. from 1985+.
Document: UPPER/LOWER WINDSHIELD/REAR GLASS TICK NOISE - REVISED Vehicle: 2006 Toyota Yaris RS 1.5 L4 GAS Symptoms: |
Document: RECALL - SEAT BELTS:FRONT:RETRACTOR Vehicle: 2006 Toyota Yaris RS 1.5 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Toyota Yaris AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Toyota Yaris SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Toyota Yaris vehicle. |
Access the Complete guide! |