Auto Parts Search
2006 Volvo S60 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Volvo -> Fuel Filter Replacement -> C70, S60, S80, V40, XC90 & S40 w/1.9L Engine
Vehicle: 2006 Volvo S60 2.5T 2.5 L5 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Always disconnect the battery ground cable before replacing the fuel filter. Position a shop towel over fuel filter connections before disconnecting.
- Connect the adapter tool (Volvo tool No. 999 5484 or equivalent), to the fuel drainage unit (Volvo tool Nos. 981 2270, 2273 and 2282 or equivalents).
- Connect the adapter to fuel rail valve. Position the fuel drainag...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2006 Volvo S60 2.5T 2.5 L5 GAS
- Raise and support vehicle on lift.
- Remove front member from body, exhaust pipe and Three-Way Catalytic Converter.
- Remove brake pipe from mountings in member. If the same driveshaft is to be reinstalled. Mark the driveshaft CV joint in relation to the bevel gear flange.
- Support the front section of the exhaust pipe so as not to put strain on the exhaust manifold.
- Remove rear exhaust system assembly.
- Remove bolts from joint using suitable tool to hold driveline while removing bolts.
- Leave one bolt in place by a few threads for safety.
- On models with vibration dampner, hold driveline...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Description
Vehicle: 2006 Volvo S60 R 2.5 L5 GAS
The TPMS (Tire Pressure Monitor System) has a CEM (Central Electronic Module), a remote RRX (Receiver Module), or a RKE (Remote keyless Entry), if keyless entry is installed. There are sensors mounted in the wheels and are activated when the vehicle exceeds 25 mph. The sensors transmit...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Starter, Replace
Vehicle: 2006 Volvo S60 R 2.5 L5 GAS
- Disconnect battery ground cable.
- Remove intake manifold between front cover plate and air cleaner housing.
- On models equipped with turbo, loosen hose clamps between charge air cooler and electronic throttle module, disconnect electrical connector and remove charge air cooler hose.
- On all model...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 1999-2006 S80, 2001-09 S60, 2001-07 V70, XC70 & 2003-09 XC90
Vehicle: 2006 Volvo S60 T5 2.4 L5 GAS
The cabin air filter should be replaced every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
- Remove the sound proofing panel from under the passenger side of the instrument panel.
- Remove the cabin air filter cover retaining screws, then the cover, Fig. .
- Press down on the cabin air filte...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Volvo -> Anti-Lock Brake System (ABS)/Dynamic Stability & Traction Control (DSTC)/Stability Traction Control (STC) Warning Lamp ->
Vehicle: 2006 Volvo S60 2.5T 2.5 L5 GAS
The warning lamp is used to warn of an system fault. The lamp input monitors the condition of the system. The lamp will be lit during engine start-up, but should go out when the self-diagnostic sy...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Radiator, Replace
Vehicle: 2006 Volvo S60 R 2.5 L5 GAS
- Remove electric cooling fan.
- On turbocharged models, disconnect charge air pipe from charge air cooler (CAC) on lefthand side. If necessary, use a hot air gun to make removal easier
- On all models, remove screws for radiator unit on front cover plate.
- Remove two upper screws holding radiator unit together.
- Remove expansion tank cap.
- Block upper radiator hose with lock grip pliers.
- Raise and support vehicle.
- Remove air baffles.
- Remove lower oil cooler hose from radiator unit. Collect oil in a suitable container.
- Remove screw for mounting for cable duct for engine wiring at front edge of...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Volvo S60 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Volvo S60 2.5T 2.5 L5 GAS
- Disconnect negative battery cable.
- Remove cover over engine control module box and move it to one side.
- Remove engine control module by carefully pulling it up and out using a suitable tool. Do not touch terminal pins on engine contro...
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Volvo S60 AUTOMOBILES
Component location diagrams for most 2006 Volvo S60 cars and light trucks sold in the U.S. from 1990+.
Engine Compartment Diagram for 2006 Volvo S60 2.5T 2.5 L5 GAS Components on diagram: |
Climate Control Components Diagram for 2006 Volvo S60 R 2.5 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Volvo S60 AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Volvo S60 cars and light trucks sold in the U.S.
2006 Volvo S60 R 2.5 L5 GAS Wiring Diagram Components on diagram: |
2006 Volvo S60 2.5T 2.5 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Volvo S60 AUTOMOBILES
OEM TSB listings for most 2006 Volvo S60 cars and light trucks sold in the U.S. from 1985+.
Document: TRANSMISSION CONTROL MODULE (TCM), SOFTWARE (SW) - REVISED Vehicle: 2006 Volvo S60 T5 2.4 L5 GAS Auto Systems: |
Document: DIFFERENTIAL ELECTRONIC MODULE (DEM), SOFTWARE (SW) - REVISED Vehicle: 2006 Volvo S60 T5 2.4 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Volvo S60 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Volvo S60 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Volvo S60 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Volvo S60 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Volvo S60 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Volvo S60 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Volvo S60 vehicle. |
Access the Complete guide! |