Auto Parts Search
2007 BMW Z4 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT BMW REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
CV AXLE SHAFT, Replace -> Front
Vehicle: 2007 BMW Z4 Roadster 3.0SI 3.0 L6 GAS
Front
The CV drive shafts differ in length. If required, mark CV drive shafts. The left CV drive shaft is shorter than the right CV drive shaft.
- Raise vehicle on lift.
- Remove front wheel lug nuts.
- Remove reinforcement plate.
- Remove engine undercover at front. There is no need to perform a front axle alignment check.
- Remove ABS pulse generator.
- Remove brake caliper and tie back.
- Force steering tie rod off swivel bearing.
- Remove tension strut with guide joint from swivel bearing.
- Remove control arm...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
Description
Vehicle: 2007 BMW Z4 Roadster 3.0SI 3.0 L6 GAS
The Tire Pressure Monitor System (TPMS) monitors the tire inflation pressure while the vehicle is being driven. To achieve this, the tire inflation pressure and tire air temperature are measured at certain intervals by sensors located on each wheel at t...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
Starter, Replace
Vehicle: 2007 BMW Z4 Coupe 3.0SI 3.0 L6 GAS
- Disconnect battery ground cable.
- Remove tension strut cover by turning counterclockwise with suitable tool. If equipped with snap out cover use suitable tool and pry upwards to remove.
- Remove screw and grip grommet and pull out tension strut from righthand side of vehicle. Do not remove grommet from bulkhead to eliminate improper installation of grommet.
- Loosen clamp and disconnect connector from air intake hose.
- Release air intake hose and remove intake filter housing bolts then remove housing.
- Remove bolts securing ignition cover.
- Remove microfilter housing by releasing cable holde...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
Cabin Air Filter Service -> BMW -> 2004-07 M Coupe, Roadster & 2004-09 Z4
Vehicle: 2007 BMW Z4 M Roadster 3.2 L6 GAS
Service interval is determined by the service indicator.
- Remove bottom righthand instrument panel attaching screws, then pull panel as indicated, Fig. .
- Disconnect plug conn...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
BMW -> Automatic Stability Control (ASC, ASC+) & Dynamic Stability Control (DSC) Warning Lamp ->
Vehicle: 2007 BMW Z4 Roadster 3.0I 3.0 L6 GAS
The warning lamp is used to warn of a system fault. It will be lit during engine start-up, but should go out when the self-diagnostic system determines that the system is functioning properly. The warning lamp will also flash when the syst...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
Radiator, Replace
Vehicle: 2007 BMW Z4 Roadster 3.0I 3.0 L6 GAS
- Disconnect temperature switch connector.
- Open coolant expansion tank cap and loosen vent screw.
- Raise and support vehicle, then remove front splash shield.
- Open radiator plug and drain coolant into suitable container.
- Open plug on righthand side of engine block near cylinder No. 2 and drain coolant into suitable container.
- Remove air duct.
- Lock belt pulley in position using holding tool No. 11 5 030, or equivalent, then remove water pump fan clutch mounting nut using wrench tool No. 11 5 040, or equivalent. Nut has lefthand threads.
- Disco...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 BMW Z4 AUTOMOBILES
Serpentine Drive Belt, Replace -> A/C Compressor Drive Belt -> Alternator Drive Belt
Vehicle: 2007 BMW Z4 Roadster 3.0I 3.0 L6 GAS
A/C Compressor Drive Belt
- Mark direction of travel and reinstall drive belt in same direction of travel, if belt is to be reused.
- Remove splash guard, if required.
- On models equipped with hydraulic tensioner,remove dust cab. Push back belt tensioner at bolt connection of guide pulley and remove drive belt.
- On models equipped with mechanical tensioner,press back drive belt tensioner at hexagon head or Torx socket and remove drive belt.
- On all models, clean pulleys and inspect for any bent or damaged pulleys.
- Rever...
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 BMW Z4 AUTOMOBILES
Component location diagrams for most 2007 BMW Z4 cars and light trucks sold in the U.S. from 1990+.
Instrument Panel Diagram for 2007 BMW Z4 Roadster 3.0SI 3.0 L6 GAS Components on diagram: |
Underbody Components Diagram for 2007 BMW Z4 Coupe 3.0SI 3.0 L6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 BMW Z4 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 BMW Z4 cars and light trucks sold in the U.S.
2007 BMW Z4 Roadster 3.0I 3.0 L6 GAS Wiring Diagram Components on diagram: |
2007 BMW Z4 Roadster 3.0SI 3.0 L6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 BMW Z4 AUTOMOBILES
OEM TSB listings for most 2007 BMW Z4 cars and light trucks sold in the U.S. from 1985+.
Document: Tools and Equipment Vehicle: 2007 BMW Z4 Roadster 3.0SI 3.0 L6 GAS Auto Systems: |
Document: Tools and Equipment Vehicle: 2007 BMW Z4 Roadster 3.0SI 3.0 L6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 BMW Z4 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 BMW Z4 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 BMW Z4 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 BMW Z4 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 BMW Z4 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 BMW Z4 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 BMW Z4 vehicle. |
Access the Complete guide! |