Auto Parts Search
2007 Pontiac G5 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
Disc Brakes -> Saturn/GM Single Piston -> Rotor, Replace -> AURA, Cobalt, G5 & ION -> L-Series -> Solstice & SKY
Vehicle: 2007 Pontiac G5 2.2 L4 GAS
AURA, Cobalt, G5 & ION
- Raise and support vehicle, then remove tire and wheel assembly.
- Compress piston into caliper bore using suitable C-clamp to allow caliper pivot upward from brake pads.
- Install and tighten two wheel nuts opposite to retain rotor to hub.
- Remove guide pin bolts, caliper and bracket.
- Mark rotor to wheel studs for installation alignment and remove rotor.
- Reverse procedure to install.
Solstice & SKY
- Raise and support vehicle, then remove tire and wheel assembly.
- Compress piston into cal...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2007 Pontiac G5 GT 2.4 L4 GAS
- Remove hub nut.
- Raise and support vehicle.
- Remove ball joint to steering knuckle nut.
- Break ball joint loose from steering knuckle.
- Push axle...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
Starter, Replace
Vehicle: 2007 Pontiac G5 GT 2.4 L4 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove terminal nuts, then disconnect starter motor electrical connecto...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2003-07 Ion, 2005-09 Cobalt & 2007-09 G5
Vehicle: 2007 Pontiac G5 GT 2.4 L4 GAS
On 2003 models, under normal operating conditions the cabin air filter should be replaced every 24 months or 18,000 miles. In dusty areas change the cabin air filter more often.
On 2004-09 models, under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the glove compartment.
- Push inward at each side of the g...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
General Motors Corp./Saturn Cars -> Traction Control System (TCS) Warning Lamp ->
Vehicle: 2007 Pontiac G5 SE 2.2 L4 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned on as a bulb check. If the warni...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 Pontiac G5 GT 2.4 L4 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from thermostat housing using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from thermostat housing.
- Reposition hose clamp from radiator using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from radiator and from vehicle.
- Reverse procedure to ...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Pontiac G5 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Pontiac G5 GT 2.4 L4 GAS
- Raise and support vehicle.
- Remove lefthand front tire and wheel assembly.
- Remove front fender inner lining and engine splash shield.
- Install a suitable acces...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Pontiac G5 AUTOMOBILES
Component location diagrams for most 2007 Pontiac G5 cars and light trucks sold in the U.S. from 1990+.
Sensor Diagram for 2007 Pontiac G5 SE 2.2 L4 GAS Components on diagram: |
Engine Diagram for 2007 Pontiac G5 2.2 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Pontiac G5 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Pontiac G5 cars and light trucks sold in the U.S.
2007 Pontiac G5 2.2 L4 GAS Wiring Diagram Components on diagram: |
2007 Pontiac G5 GT 2.4 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Pontiac G5 AUTOMOBILES
OEM TSB listings for most 2007 Pontiac G5 cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2007 Pontiac G5 2.2 L4 GAS Auto Systems: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Pontiac G5 2.2 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Pontiac G5 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Pontiac G5 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Pontiac G5 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Pontiac G5 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Pontiac G5 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac G5 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Pontiac G5 vehicle. |
Access the Complete guide! |