Auto Parts Search
2007 Volkswagen EOS CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volkswagen REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
CV AXLE SHAFT, Replace -> With CV Joint and Triple Roller Joint -> With Triple Roller Joint
Vehicle: 2007 Volkswagen EOS 3.2 3.2 V6 GAS
With CV Joint and Triple Roller Joint
Wheel bearing must not be burdened while 12 point nut is loose.
If wheel bearing is burdened by weight of vehicle, wheel bearing will be pre-damaged. This will diminish wheel bearing service life.
If it should be necessary to move a vehicle whose drive axle has been removed, before doing so install an outer joint in place of drive axle and tighten it to 11 ft. lbs., or else wheel bearing will be damaged.
- Lift vehicle enough that front axle is no longer burdened.
- Remove 12 point nut.
- Raise and support vehicle.
- Remove wheel.
- Remove sound insula...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
Component Locations
Vehicle: 2007 Volkswagen EOS 2.0T 2.0 L4 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
Starter, Replace
Vehicle: 2007 Volkswagen EOS 2.0T 2.0 L4 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove sound insulation cover.
- Remove screws, open mounting clips and pull hose out of air filter housing.
- Disconnect electrical connector at Mass Air Flow (MAF) Sensor.
- Remove engine cover by pulling upward.
- Remove ground wire from transmission.
- Slide back protective cap and disconnect starter elec...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
Cabin Air Filter Service -> Volkswagen -> 2005-09 GLI, GTI, Jetta, 2006-09 Passat, Rabbit, 2007-09 Eos & 2009 Tiguan
Vehicle: 2007 Volkswagen EOS 3.2 3.2 V6 GAS
On 2005-06 models, the cabin air filter should be replaced every 24 months or 20,000 miles.
On 2007-08 models, the cabin air filter should be replaced every 24 months or 40,000 miles. The filter should be replaced more often if air flow is less than normal.
On 2009 models, the cabin air filter should be replaced every 24 months or 20,000 mi...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
Volkswagen -> Service Reminder Indicator Lamp -> 2007-09 Eos
Vehicle: 2007 Volkswagen EOS 3.2 3.2 V6 GAS
- Connect VW tester or equivalent.
- Select:
- Manufacturer.
- Model.
- Model Year.
- Engine Code.
- Confirm Vehicle Identification.
- Instrument Cluster.
- Reset Service Reminder Indicator.
- Follow the instructions indicated on the tester display.
- After completing the displa...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2007 Volkswagen EOS 2.0 L4 GAS
Inlet
- Drain coolant into a suitable container.
- Reposition hose clamp at heater core and remove hose.
- Reposition hose clamp at coolant connection and remove hose.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Volkswagen EOS AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Volkswagen EOS 3.2 3.2 V6 GAS
- Raise and support vehicle.
- Remove sound insulation.
- Disconnect vent line (white) and remove EVAP canister from bracket.
- Mark direction of rotation of drive belt with chalk or felt pen if belt is to be...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Volkswagen EOS AUTOMOBILES
Component location diagrams for most 2007 Volkswagen EOS cars and light trucks sold in the U.S. from 1990+.
Engine Components Diagram for 2007 Volkswagen EOS 3.2 3.2 V6 GAS Components on diagram: |
Window Control Components Diagram for 2007 Volkswagen EOS 3.2 3.2 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Volkswagen EOS AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Volkswagen EOS cars and light trucks sold in the U.S.
2007 Volkswagen EOS 2.0 L4 GAS Wiring Diagram Components on diagram: |
2007 Volkswagen EOS 3.2 3.2 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Volkswagen EOS AUTOMOBILES
OEM TSB listings for most 2007 Volkswagen EOS cars and light trucks sold in the U.S. from 1985+.
Document: Radio, Entering and Retrieving Anti-Theft (SAFE) Code Vehicle: 2007 Volkswagen EOS 2.0 L4 GAS Auto Systems: |
Document: Radio Coding - Auxiliary Jack, iPod Inop After Radio Replacement Vehicle: 2007 Volkswagen EOS 2.0 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Volkswagen EOS AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Volkswagen EOS cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Volkswagen EOS cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Volkswagen EOS cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Volkswagen EOS cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen EOS SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Volkswagen EOS vehicle. |
Access the Complete guide! |