Auto Parts Search
2009 Chevrolet Silverado 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Chevrolet Silverado 1500 LTZ 5.3 V8 FLEX
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Remove drive axle center cap, if equipped.
- Insert a drift or large screwdriver through brake caliper into one of the brake rotor vanes in order to prevent drive axle wheel drive shaft from turning.
- Remove nut and washer from hub. Do not reuse nut. A new nut must be used when installing wheel drive shaft.
- Using axle remover tool No. J 45859 or equivalent, press wheel drive shaft from hub.
- Remove bolts securing wheel drive s...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
Reset Procedures
Vehicle: 2009 Chevrolet Silverado 1500 LTZ 6.2 V8 FLEX
The Low Tire Pressure warning lamp and/or the DIC (Driver Information Center) Low Tire Pressure message can be cl...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
Starter, Replace
Vehicle: 2009 Chevrolet Silverado 1500 LTZ 5.3 V8 FLEX
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove transmission cover bolt.
- Remove starter mounting bolts.
- Disconnect engine wiring harness electrical connector from oil level sensor. Avoid cable and wiring damage. DO NOT suspend starter by cables or wires attached to solenoid terminals. Use a rope or mechanics wire to suspend starter.
- Slide starter forward until starter clears transmission and properly support starter.
- Lower vehicle half way.
- Remove right front wheel and tire.
- Remove right front wheelhouse liner.
- Remove engine wiring ha...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Change Oil, Change Oil Now Or Change Oil Soon Lamp & Messages -> 2007-09 Sierra & Silverado -> Less Driver Information Center (DIC) -> With Driver Information Center (DIC)
Vehicle: 2009 Chevrolet Silverado 1500 LT 5.3 V8 FLEX
Less Driver Information Center (DIC)
- Turn ignition On, but do not start engine.
- Fully depress and release accelerator pedal three times within five seconds.
- Place the ignition switch in the Off position.
- If the Change Oil Soon Message comes back On when starting the vehicle, the Engine Oil Life system has not reset. Repeat the procedure to reset the Engine Oil Life system
With Driver Information Center (DIC)
- Turn ig...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
Radiator, Replace
Vehicle: 2009 Chevrolet Silverado 1500 WT 5.3 V8 FLEX
- Drain cooling system into a suitable container.
- Remove cooling fan and shroud.
- Remove radiator outlet hose.
- Disconnect engine oil cooler lines from radiator.
- Disconnect transmission oil cooler lines from radiator.
- Remove radiator bolts.
- Remove rad...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Chevrolet Silverado 1500 LT 5.3 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
OEM TSB listings for most 2009 Chevrolet Silverado 1500 cars and light trucks sold in the U.S. from 1985+.
Document: BluetoothA® Option Availability Vehicle: 2009 Chevrolet Silverado 1500 Hybrid 6.0 V8 ELECTRIC/GAS Auto Systems: |
Document: Intermittent Engine Stall on Deceleration During Extreme High Ambient Temperatures Vehicle: 2009 Chevrolet Silverado 1500 WT 5.3 V8 FLEX Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Chevrolet Silverado 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Chevrolet Silverado 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Chevrolet Silverado 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Chevrolet Silverado 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Chevrolet Silverado 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Silverado 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Chevrolet Silverado 1500 vehicle. |
Access the Complete guide! |