Auto Parts Search
2009 Dodge RAM 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Dodge RAM 1500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble -> U-Joint with Injected Rings -> U-Joint with Snap Rings
Vehicle: 2009 Dodge RAM 1500 Laramie 5.7 V8 GAS
This procedure describes a propeller shaft equipped with a cardan joint in the tube yoke. For propeller shafts equipped with a companion/slip yoke, repeat the steps to remove the remaining cardan joint.
U-Joint with Snap Rings
Disassemble
- Tap outside of bearing cap with a drift to loosen snap ring.
- Remove snap rings from both sides of yoke.
- Position yoke with grease fitting if equipped, pointing up.
- Position a socket with a inside diameter large enough to receive bearing cap, beneath yoke on a press.
- Place another socket with an outside diameter smaller than bearing cap on ...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Dodge RAM 1500 AUTOMOBILES
Reset Procedures
Vehicle: 2009 Dodge RAM 1500 TRX 5.7 V8 GAS
The Low Tire Pressure indicator lamp will flash slowly and sound a single tone when tire pressure is low. If tire pressure drops lower, the indicator lamp will flash rapidly and the tone will be continuous. When the tir...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Dodge RAM 1500 AUTOMOBILES
Starter, Replace
Vehicle: 2009 Dodge RAM 1500 TRX 5.7 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- On 4WD models, a support bracket is used between front axle and side of transmission. Remove two support bracket bolts at transmission. Pry support bracket slightly to gain access to lower starter mounting bolt.
- On all models, remove two starter mounting bolts.
- Move starter motor towards front of vehicle far enough for nose of starter pinion housing to clear housing. Always support starter motor during this process, do not let starter motor hang from wire harness.
- Tilt nose do...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Dodge RAM 1500 AUTOMOBILES
Chrysler LLC Trucks -> Change Engine Oil Indicator -> 2007-09 Ram 1500-3500
Vehicle: 2009 Dodge RAM 1500 Sport 5.7 V8 GAS
The CHANGE OIL message will flash in the instrument cluster odometer for approximately 12 seconds after a single chime has sounded to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may flu...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Dodge RAM 1500 AUTOMOBILES
Radiator, Replace
Vehicle: 2009 Dodge RAM 1500 TRX 5.7 V8 GAS
- Disconnect negative battery cable.
- Drain cooling system into a suitable container.
- Remove pushpins and upper condenser/radiator seal.
- Remove air filter housing assembly.
- Remove upper radiator hose.
- Remove overflow tube.
- Remove radiator fan shroud from radiator and position over radiator fan.
- Remove upper radiator support.
- Raise and support vehicle.
- Disconnect power steering c...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Dodge RAM 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Dodge RAM 1500 Sport 5.7 V8 GAS
- Remove air intake tube between intake manifold and air filter.
- Release belt tension by rotating tensioner counterclockwise with suitable wrench on tensioner pulley bolt.
- Rotate belt tensioner until belt can be removed from pull...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Dodge RAM 1500 AUTOMOBILES
OEM TSB listings for most 2009 Dodge RAM 1500 cars and light trucks sold in the U.S. from 1985+.
Document: Flash: TIPM Upgrade For Difficulty Flashing The Powertrain Control Module Vehicle: 2009 Dodge RAM 1500 SLT 4.7 V8 FLEX Auto Systems: |
Document: CUSTOMER SATISFACTION NOTIFICATION J06 WINDSHIELD WASHER FLUID LEVEL SENSOR Vehicle: 2009 Dodge RAM 1500 SLT 4.7 V8 FLEX Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Dodge RAM 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Dodge RAM 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Dodge RAM 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Dodge RAM 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Dodge RAM 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge RAM 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Dodge RAM 1500 vehicle. |
Access the Complete guide! |