Auto Parts Search
2009 Ford F-250 Super Duty CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service

DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Ford F-250 Super Duty AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble -> Double Cardan -> Single Cardan, Flange Yoke -> Single Cardan, Slip Yoke
Vehicle: 2009 Ford F-250 Super Duty XL 6.4 V8 DIESEL
Single Cardan, Slip Yoke
Disassemble
Do not, under any circumstance, clamp the shaft in the jaws of a vise or similar holding fixture. Denting or localizing fracture can result, causing shaft failure during vehicle operation. Place the shaft on a suitable workbench. Do not damage the tube. If components are not marked and installed incorrectly, driveline imbalance can occur.
- Index-mark the shaft components.
- Remove and discard all four snap rings.
- Clamp bearing cup removal tool No. 205-086 or equivalent in a vise.
- If necessary, use a pair of pliers to remove a bearing cup t...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Ford F-250 Super Duty AUTOMOBILES
Relearn Procedures -> TPMS Sensor Activation -> TPMS Sensor Training
Vehicle: 2009 Ford F-250 Super Duty HARLEY-DAVIDSON Edition 6.4 V8 DIESEL
TPMS Sensor Activation
To conserve battery power, the TPMS sensors will go into a sleep mode after approximately 30 minutes of inactivity. The sensors will not transmit tire pressure information while in sleep mode. The sensors must be activated to transmit the latest tire pressure information.
- Place the ignition switch in the On position.
- Position Ford TPMS activation tool, or equivalent, against the LF tire side wall 180° from the valve stem.
- The TPMS activation tool will flash a green light and sound a beep for each successful response from a TPMS sensor.
- Press the TPMS activat...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Ford F-250 Super Duty AUTOMOBILES
Starter, Replace
Vehicle: 2009 Ford F-250 Super Duty XLT 6.4 V8 DIESEL
Before carrying out maintenance on the starting system, disconnect the battery ground cable from the frame to completely isolate the starter from the dual frame-mounted batteries. Failure to follow this instruction may result in serious personal injury.
- Disconnect ground cables for dual batteries. Ground path is through the frame.
- Remove nut and position cable bracket aside.
- Remove starter solenoid protective cap.
- Disconnect starter...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Ford F-250 Super Duty AUTOMOBILES
Ford Motor Co. Trucks -> Low Oil Level Warning Indicator ->
Vehicle: 2009 Ford F-250 Super Duty Lariat 6.4 V8 DIESEL
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Ford F-250 Super Duty AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2009 Ford F-250 Super Duty Lariat 5.4 V8 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Remove hose from oil filter adapter hose and heater tube assembly.
- Reposition hose clamp from oil filter adapter.
- Remove radiator outlet hose from oil filter adapter...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Ford F-250 Super Duty AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Ford F-250 Super Duty XLT 5.4 V8 GAS
- Rotate drive belt tensioner counterclockwise, using a 1/2 square hole in drive belt tensioner pull...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Ford F-250 Super Duty AUTOMOBILES
OEM TSB listings for most 2009 Ford F-250 Super Duty cars and light trucks sold in the U.S. from 1985+.
Document: 6.4L Diesel - Cold Weather Belt Chirp Vehicle: 2009 Ford F-250 Super Duty XLT 6.4 V8 DIESEL Symptoms: |
Document: SLOW FUEL FILL - 5.4 AND 6.8 ENGINES Vehicle: 2009 Ford F-250 Super Duty XLT 5.4 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Ford F-250 Super Duty AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Ford F-250 Super Duty cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Ford F-250 Super Duty cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Ford F-250 Super Duty cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Ford F-250 Super Duty cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-250 Super Duty SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
![]() |
Access the Complete guide! |