Auto Parts Search
2009 Mazda MX-5 Miata CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Mazda REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Mazda MX-5 Miata AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Mazda MX-5 Miata Grand Touring 2.0 L4 GAS
Performing the following procedures without first removing the ABS wheel-speed sensor may possibly cause an open circuit in the wiring harness if pulled by mistake. Before performing the following procedures, disconnect the ABS wheel speed sensor connector (axle side) and fix the wiring harness to an appropriate place where it will not be pulled by mistake while servicing vehicle.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Drain transaxle fluid into suitable container.
- Disconnect ABS wheel speed sensor.
- ...
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Mazda MX-5 Miata AUTOMOBILES
Component Replacement -> Pressure Monitor Sensor (Valve Stem Type)
Vehicle: 2009 Mazda MX-5 Miata Sport 2.0 L4 GAS
Pressure Monitor Sensor (Valve Stem Type)
Use of a digital gauge is recommended for accurate measurement of air pressure. Place air chuck straight on the valve stem to inflate tire. Do not cock air chuck during inflation cycle. Doing so can damage valve stem and cause air leaks.
- Remove wheel, tire assembly and then the valve cap.
- Remove the valve core of wheel nut and bleed air from the tire.
- Remove the nut and washer.
- Push tire valve completely into tire. Breaking tire bead with wheel unit installed normally could damage unit. Be sure to always push wheel unit so that it is co...
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Mazda MX-5 Miata AUTOMOBILES
Starter, Replace
Vehicle: 2009 Mazda MX-5 Miata Sport 2.0 L4 GAS
- Unhook battery cover from battery box.
- Disconnect battery ground cable.
- Raise vehicle on lift.
- Remove retainers securing lefthand side cover then remove cover.
- Remove under cover bolts then remove undercover.
- On models equipped with manual transaxle, proceed as follows:
- Remove clutch release cylinder with pipe still connected.
- Position clutch release cylinder out of way.
- On all models, remove oil filter, drain oil in suitable container.
- On models equipped with oil cooler, proceed as follows:
- Remove oil cooler and oil filter adapter component with coolant hoses attached, drain oil in suit...
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Mazda MX-5 Miata AUTOMOBILES
Mazda -> Check Fuel Cap Lamp ->
Vehicle: 2009 Mazda MX-5 Miata Touring 2.0 L4 GAS
The Check Fuel Cap Lamp will illuminate momentarily when the ignition switch is placed in the On position as a bulb check. If the lamp remain...
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Mazda MX-5 Miata AUTOMOBILES
Radiator, Replace
Vehicle: 2009 Mazda MX-5 Miata Touring 2.0 L4 GAS
- Drain engine coolant into a suitable container, then remove engine undercover.
- Remove air intake pipe, Fig. .
- Remove radiator hoses and coolant bottle hose.
- On models equipped with automatic transmission,disconne...
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Mazda MX-5 Miata AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Mazda MX-5 Miata SV 2.0 L4 GAS
- Remove battery and battery tray.
- Set a breaker bar on center of tensioner pulley.
- Turn c...
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Mazda MX-5 Miata AUTOMOBILES
OEM TSB listings for most 2009 Mazda MX-5 Miata cars and light trucks sold in the U.S. from 1985+.
Document: SERVICE POINTS FOR ENGINE REPLACEMENT DUE TO ENGINE NOISE Vehicle: 2009 Mazda MX-5 Miata Touring 2.0 L4 GAS Symptoms: |
Document: SERVICE BUMPER SPECIFICATION CHANGE Vehicle: 2009 Mazda MX-5 Miata Touring 2.0 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Mazda MX-5 Miata AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Mazda MX-5 Miata cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Mazda MX-5 Miata cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Mazda MX-5 Miata cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Mazda MX-5 Miata cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Mazda MX-5 Miata SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Mazda MX-5 Miata vehicle. |
Access the Complete guide! |