Auto Parts Search
2009 Toyota Yaris CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Toyota Yaris 1.5 L4 GAS
- Raise and support vehicle.
- Remove engine under cover.
- Drain transmission fluid into a suitable container.
- Remove wheel lug nuts.
- Remove front axle hub nut.
- Remove bolt and separate speed sensor and flexible hose.
- Remove nut and separate stabilizer link from shock absorber.
- Remove cotter pin and castle nut from tie rod.
- Make sure upper ends of threaded section of tie rod end and SST (spacer B) are aligned.
- Separate tie rod end from front axle assembly.
- Remove clip and castle nut from lower control arm.
- Separate front lower contr...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
Wiring Diagrams -> Wire Color Code Identification
Vehicle: 2009 Toyota Yaris 1.5 L4 GAS
Refer to Fig. for wiring...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Toyota Yaris 1.5 L4 GAS
- Disconnect cable from battery ground terminal.
- Remove righthand engine under cover.
- Remove fan and alternator V belt.
- Remove terminal cap.
- Separate connector and harness clamp.
- Remove nut and remove terminal B+.
- Remove fan belt adjusting slider fixing bolts and remove fan belt...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
Cabin Air Filter Service -> Toyota -> 2007-09 Yaris
Vehicle: 2009 Toyota Yaris S 1.5 L4 GAS
The cabin air filter should be replaced every 36 months or 30,000 miles. The filter should be replaced more often if air flow is less than normal.
- Open the glove compartment door, then disconnect the damper rod from the glove compartment, Fig. .
- Push inward at both sides of the glove compartment, then pull the glove compartment downward.
- Through the glove compartment opening, release two retaining clips securing filter cover to A/C unit and remove the filter cover, Fig. .
- Remove the cabin air filter element fro...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
Toyota -> Malfunction Indicator Lamp (MIL) ->
Vehicle: 2009 Toyota Yaris 1.5 L4 GAS
On some models equipped with OBD II, the MIL will also illuminate if the fuel tank filler cap is not properly tightened. Tighten fuel tank filler cap until it clicks.
The MIL should light when the ignition switch is placed in the On position without starting the engine. When the engine is started, the lamp should go out. If it remains lit, a fault has been detected by the diagnostic system and has logged a diagnostic trouble code. If the fault does not occur again within three trips, the lamp will go out but a diagnostic tro...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2009 Toyota Yaris 1.5 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet housing.
- Remove hose from water inlet housing.
- Remove hose from vehicle.
- Reverse pr...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Toyota Yaris AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Toyota Yaris S 1.5 L4 GAS
- Remove bolts from righthand engine cover assembly, then remove cover.
- Loosen bolts from upper and lower alternator mounting bracket.
- Rotate or lift belt tensioner arm counterclockwise, using a suitable tool to relieve tension from...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Toyota Yaris AUTOMOBILES
OEM TSB listings for most 2009 Toyota Yaris cars and light trucks sold in the U.S. from 1985+.
Document: Rattle Noise From Automatic Transmission Control Cable Assembly In Reverse Vehicle: 2009 Toyota Yaris S 1.5 L4 GAS Symptoms: |
Document: XM SATELLITE RADIO INOPERATIVE UNTIL IGNITION KEY IS CYCLED Vehicle: 2009 Toyota Yaris S 1.5 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Toyota Yaris AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota Yaris SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Toyota Yaris vehicle. |
Access the Complete guide! |