Auto Parts Search
Toyota Echo CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Year
| 2005 | 2004 | 2003 | 2002 |
| 2001 | 2000 |
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about Toyota Echo car and truck
repair procedures including Toyota engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Toyota Echo automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR Toyota Echo AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported Toyota Echo cars and light trucks from 1990+
Toyota -> Component Replacement & Adjustment -> Blower Motor, Replace -> 4Runner -> Avalon, Camry & Camry Solara -> Celica -> Cooling Unit -> Corolla -> Echo -> Front -> Heating Unit -> Highlander -> Land Cruiser -> MR2 -> RAV4 -> Rear -> Sequoia -> Sienna -> Tacoma -> Tundra
Vehicle: 2002 Toyota Echo 1.5 L4 GAS
Avalon, Camry & Camry Solara
- Remove glove compartment and undercover.
- Disconnect blower motor electrical connector.
- Remove blower motor attaching screws, then the blower motor.
- Reverse procedure to install.
Celica
- Remove glove compartment.
- Disconnect blower motor electrical connector.
- Remove three blower motor attaching screws, then the blower motor.
- Reverse procedure to install.
Corolla
- Remove righthand scuff plate.
- Remove righthand cowl side trim.
- Remove lower panel below glove compar...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR Toyota Echo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported Toyota Echo cars and light trucks from 1990+.
Power Brake Units -> Troubleshooting
Vehicle: 2002 Toyota Echo 1.5 L4 GAS
Refer to "Hydraulic Brake Systems" ...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR Toyota Echo AUTOMOBILES
Fuel filter replacement procedures with corresponding images for most domestic and imported Toyota Echo cars and light trucks sold in the U.S. for 1980+.
Toyota -> Fuel Filter Replacement -> Echo, Prius & Yaris -> Fuel System Pressure Relief -> Models Less Union Bolt Fuel Line Connection -> Models w/Union Bolt Fuel Line Connection -> Removal & Installation
Vehicle: 2001 Toyota Echo 1.5 L4 GAS
Fuel System Pressure Relief
Models w/Union Bolt Fuel Line Connection
- Obtain the vehicle owners radio theft protection code prior to disconnecting the battery ground cable, if equipped.
- Disconnect the battery ground cable.
- Remove the fuel fill cap to release fuel tank pressure.
- Place a shop towel over the union bolt at top of fuel filter. Slowly loosen the union bolt allowing fuel pressure to bleed down.
- Whenever the union bolt is loosened to relieve fuel system pressure, always replace the bolt gasket.
Models Less Union Bolt Fuel Line Connection
- Obtain the vehicle owners radio theft...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR Toyota Echo AUTOMOBILES
Includes CV axle, universal joint, and driveline replacement, for domestic and imported Toyota Echo cars and light trucks from 1990+.
CV AXLE SHAFT, Replace
Vehicle: 2001 Toyota Echo 1.5 L4 GAS
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Drain transmission fluid.
- Unstake driveshaft hub nut.
- With an assistant applying brakes, remove driveshaft hub nut.
- Remove clip and nut from lower ball joint, then disconnect ball joint from lower control arm.
- Remove cotter pin and nut, then disconnect tie rod assembly from steering knuckle.
- Disconnect drive shaft from axle hub assembly, using a plasti...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR Toyota Echo AUTOMOBILES
Includes starter and alternator replacement procedures for domestic and imported Toyota Echo cars and light trucks from 1990+.
Starter, Replace
Vehicle: 2002 Toyota Echo 1.5 L4 GAS
- Disconnect battery ground cable.
- Remove engine under covers, then disconnect starter connector.
- Re...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR Toyota Echo AUTOMOBILES
Cabin air filter locations and replacement procedures with corresponding images for most domestic and imported Toyota Echo cars and light trucks sold in the U.S. as equipped to the current model year.
Cabin Air Filter Service -> Toyota -> 2000-05 Echo
Vehicle: 2002 Toyota Echo 1.5 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 22,500 miles. In dusty areas change the cabin air filter every 10,000 miles.
- Open the glove compartment door.
- Push inward at both sides of the glove compartment, then pull the glove compartment downward, Fig. .
- Through the glove compartment opening, release two retaining clips securing filter housing to A/C unit and remove the filter housing, Fig. .
- Remove the cab...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR Toyota Echo AUTOMOBILES
Maintenance lamp reset procedures with corresponding images for most domestic and imported Toyota Echo cars and light trucks sold in the U.S. from 1990+.
Toyota -> Malfunction Indicator Lamp (MIL) ->
Vehicle: 2005 Toyota Echo 1.5 L4 GAS
On some models equipped with OBD II, the MIL will also illuminate if the fuel tank filler cap is not properly tightened. Tighten fuel tank filler cap until it clicks.
The MIL should light when the ignition switch is placed in the On position without starting the engine. When the engine is started, the lamp should go out. If it remains lit, a fault has been detected by the diagnostic system and has logged a diagnostic trouble code. If the fault does not occur again within three trips, the lamp will go out but a diagnostic tro...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR Toyota Echo AUTOMOBILES
Includes radiator, cooling and heater hose replacement procedures for domestic and imported Toyota Echo cars and light trucks from 1990+
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2002 Toyota Echo 1.5 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR Toyota Echo AUTOMOBILES
Serpentine belt replacement procedures with corresponding images for most domestic and imported Toyota Echo cars and light trucks sold in the U.S. from 1990+.
Serpentine Drive Belt, Replace
Vehicle: 2005 Toyota Echo 1.5 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO Toyota Echo SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR Toyota Echo AUTOMOBILES
Component location diagrams for most Toyota Echo cars and light trucks sold in the U.S. from 1990+.
 Automatic Transaxle Diagram for 2001 Toyota Echo 1.5 L4 GASComponents on diagram: |
 Ignition Switch And Key Unlock Warning Switch Diagram for 2002 Toyota Echo 1.5 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO Toyota Echo PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR Toyota Echo AUTOMOBILES
OEM drawn wiring diagrams for most Toyota Echo cars and light trucks sold in the U.S.
 2004 Toyota Echo 1.5 L4 GAS Wiring DiagramComponents on diagram: |
 2003 Toyota Echo 1.5 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO Toyota Echo WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR Toyota Echo AUTOMOBILES
OEM TSB listings for most Toyota Echo cars and light trucks sold in the U.S. from 1985+.
|
Document: REPAIR MANUAL SUPPLEMENT: VEHICLE PULLING TO ONE SIDE - REVISED Vehicle: 2002 Toyota Echo 1.5 L4 GAS Symptoms: |
|
Document: PAINT STAINS UNDER THE RAPGARD - REVISED Vehicle: 2005 Toyota Echo 1.5 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO Toyota Echo TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR Toyota Echo AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most Toyota Echo cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most Toyota Echo cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most Toyota Echo cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most Toyota Echo cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO Toyota Echo SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your Toyota Echo vehicle.
|
| Access the Complete guide! |
