Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 1997 Chevrolet G10 VAN car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 1997 Chevrolet G10 VAN automobile. Try the Automotix DIY solution today!
We have info for following modifications of 1997 Chevrolet G10 VAN
- 1997 Chevrolet G10 VAN Express 5.7 V8 GAS, CID:350, Fuel Injection, Aspiration:350, Engine VIN:, Desg:R
- 1997 Chevrolet G10 VAN Express 4.3 V6 GAS, CID:262, Fuel Injection, Aspiration:262, Engine VIN:, Desg:W
- 1997 Chevrolet G10 VAN Express 5.0 V8 GAS, CID:305, Fuel Injection, Aspiration:305, Engine VIN:, Desg:M
BRAKE SERVICE PROCEDURES FOR 1997 Chevrolet G10 VAN AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Chevrolet G10 VAN cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Rotor Replacement -> 2WD Models -> 4WD Models -> Astro, Blazer, Bravada, Jimmy, K1500/2500 & T Series Pickup -> Except Montana, Silhouette, Trans Sport & Venture -> Front -> K3500 -> Montana, Silhouette, Trans Sport & Venture -> Rear
Vehicle: 1997 Chevrolet G10 VAN Express 5.0 V8 GAS
2WD Models
Except Montana, Silhouette, Trans Sport & Venture
Front
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Remove caliper as outlined under "Caliper Service."
- Remove grease cap from hub/rotor, Fig. .
- Remove cotter pin, nut and washer.
- Remove hub/rotor from spindle, being careful not to damage spindle threads or outer bearing.
- Reverse procedure to install, noting the following:
- Apply high-temperature wheel bearing grease to inner and outer wheel bearings.
- Torque nut to 12 ft. lbs. while turning wheel assembly forward by hand, back nut off one flat or until hole in spindle...
CLICK HERE TO GET FULL ACCESS TO 1997 Chevrolet G10 VAN BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Chevrolet G10 VAN AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Chevrolet G10 VAN cars and light trucks from 1990+.
Anti-lock Brakes -> Kelsey-Hayes -> Precautions -> Battery Ground Cable -> Delco LOC II -> General Service Precautions -> Radio Security System -> Theftlock
Vehicle: 1997 Chevrolet G10 VAN Express 5.7 V8 GAS
Battery Ground Cable
Prior to service disconnect battery ground cable and isolate as required.
Radio Security System
Theftlock
If the Theftlock system is active when battery power is interrupted, the customers security code must be entered to restore proper function of the radio. To unlock a secured radio after power loss, proceed as follows:
- "LOC" appears with ignition in On position.
- Press "NM" and "000" will appear on display.
- Press "NM" again to make last two digits agree with security code.
- Press "HR" to make first 1 or 2 digits agree with security code.
- Press "AM-FM" to select code entered. "SEC" wi...
CLICK HERE TO GET FULL ACCESS TO 1997 Chevrolet G10 VAN BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Chevrolet G10 VAN AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Chevrolet G10 VAN cars and light trucks from 1990+.
Power Brake Units -> Bendix Brake Booster -> General Service
Vehicle: 1997 Chevrolet G10 VAN Express 5.7 V8 GAS
Certain general service procedures apply, regardless of whether the brakes are vacuum or hydraulically assisted. Only top quality, clean brake fluid should be used. More seals and valves are used with power brake systems than with ordinary brakes, so an inferior brake fluid will do much more damage. For the same reason, ensure all dirt is kept out of the system. Additionally, care must be taken not to mix the fluids of the booster hydraulic system and brake hydraulic system as the fluids are not compatible.
If the power unit fails, the brakes will still operate, as the convention...
CLICK HERE TO GET FULL ACCESS TO 1997 Chevrolet G10 VAN BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Chevrolet G10 VAN AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Chevrolet G10 VAN cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Description
Vehicle: 1997 Chevrolet G10 VAN Express 5.0 V8 GAS
The caliper assembly slides on its mounting surfaces, Fig. . Upon brake application, hydraulic pressure against the piston forces the inboard pad against the inboar...
CLICK HERE TO GET FULL ACCESS TO 1997 Chevrolet G10 VAN BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Chevrolet G10 VAN AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Chevrolet G10 VAN cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Brake System Bleed
Vehicle: 1997 Chevrolet G10 VAN Express 5.7 V8 GAS
Refer to "Hydraulic Brake... "
CLICK HERE TO GET FULL ACCESS TO 1997 Chevrolet G10 VAN BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Chevrolet G10 VAN AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Chevrolet G10 VAN cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Brake Pad Service -> Installation -> Removal
Vehicle: 1997 Chevrolet G10 VAN Express 5.7 V8 GAS
Removal
- Remove caliper as outlined under "Caliper Service."
- Remove inboard pad with retainer spring.
- Remove outboard pad and position caliper on front suspension so brake hose will not support weight of caliper.
- Remove two sleeves from inboard ears of caliper.
- Remove four rubber bushings from grooves in each of caliper ears.
Installation
- Lubricate new sleeves, rubber bushings, bushing grooves and mounting bolt ends with lubricant part No. 19010909, or equivalent.
- Install new bushings and sleeves in caliper e...
CLICK HERE TO GET FULL ACCESS TO 1997 Chevrolet G10 VAN BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 1997 Chevrolet G10 VAN vehicle.
|
| Access the Complete guide! |
