Auto Parts Search
1999 Suzuki Vitara CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Suzuki REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 1999 Suzuki Vitara car and truck
repair procedures including Suzuki engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Suzuki Vitara automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Suzuki -> Component Replacement & Adjustment -> Cooling System Bleed
Vehicle: 1999 Suzuki Vitara 1.6 L4 GAS
A specific bleed procedure is not required. After filling cooling system, run engine t...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Anti-lock Brakes -> System Service -> ABS Control Module -> ABS Electronic Control Unit -> ABS Hydraulic Control Unit -> ABS Hydraulic Modulator & Master Cylinder Assembly -> ABS Hydraulic Modulator Gears -> ABS Hydraulic Modulator Solenoid Assembly -> ABS Lamp Driver Module -> Brake System Bleed -> Component Replacement -> Control Module -> Electronic Brake Control Module (EBCM) -> Enable Relay -> Esteem -> Front Wheel Speed Sensor -> G Sensor -> Grand Vitara & Vitara -> Rear Wheel Speed Sensor -> Sidekick & X90 -> Swift
Vehicle: 1999 Suzuki Vitara 1.6 L4 GAS
Brake System Bleed
Brake fluid is extremely damaging to paint. If fluid should accidentally touch painted surface, immediately wipe fluid from paint and clean painted surface.
The hydraulic lines of the brake system are based on a diagonal split system. When a brake line or hose is disconnected, bleeding operation must be performed at both ends of the line disconnected.
- Fill master cylinder reservoir. Reservoir should be kept at least half full during bleeding operation.
- Remove bleeder plug cap, then attach vinyl tube to bleeder plug of component to be bled. Insert other end of tube ...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Suzuki -> Fuel Filter Replacement -> Grand Vitara, Verona, Vitara & XL-7 -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 1999 Suzuki Vitara 1.6 L4 GAS
Fuel System Pressure Relief
- Loosen the fuel filler cap to relieve fuel tank pressure.
- Remove the fuel pump relay/fuse from relay or fuse box located in engine compartment.
- Start the engine and allow to stall. Crank the engine for several seconds more to ensure relief of any remaining fuel pressure.
- Disconnect the battery ground cable.
- Install the fuel pump relay/fuse.
Removal & Installation
Do not smoke or allow an open flame of any type when working on or near any fuel system related componen...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1999 Suzuki Vitara 2.0 L4 GAS
- Raise and support vehicle, then remove wheel and tire assembly.
- Remove axle shaft drive flange or hub cap.
- On models equipped with ABS, remove wheel speed sensor from knuckle and harness clamp from strut.
- Remove caliper bolt, then suspend caliper.
- Remove brake disc.
- Remove front wheel bearing lock washer by loosening four screws.
- Remove front wheel bearing lock nut using special tool No. 09951-16050, or equivalent.
- Remove front wheel bearing washer.
- Remove wheel hub ...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Starter, Replace
Vehicle: 1999 Suzuki Vitara 2.0 L4 GAS
- Disconnect battery ground cable.
- Disconnect solenoid electrical connector and battery cabl...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Cabin Air Filter Service -> Suzuki -> 1999-2002 Grand Vitara, 1999-2004 Vitara & 2001-02 XL-7
Vehicle: 1999 Suzuki Vitara 1.6 L4 GAS
Inspect the cabin air filter every 15,000 miles and replace as required. The cabin air filter should be replaced every 30,000 miles.
- Disconnect and isolate the battery ground cable. Wait at least 90 seconds for the air bag system back-up power supply to discharge.
- Remove the air bag fuse from the fuse panel located at the lower lefthand side of the instrument panel.
- From under the lefthand side of the instrument panel, disconnect the yellow air bag system contact coil electrical connector, Fig. . Lift up the connector locking lever, then disc...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Suzuki -> Anti-Lock Brake System Warning Lamp -> 1999-2004 Vitara
Vehicle: 1999 Suzuki Vitara 2.0 L4 GAS
The Anti-Lock Brake System (ABS) indicator lamp should illuminate for approximately 2 seconds as a bulb check when the ignition Switch is placed in the on position. If the lamp remains illuminated or comes on while driving the vehicle or is blinking, a fault in the ABS has been detected. After diagnosis and repair are completed, the DTCs can be cleared using a suitable scan tool or as follows:
- Place ignition switch in the off position.
- C...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Radiator, Replace
Vehicle: 1999 Suzuki Vitara 2.0 L4 GAS
- Drain coolant into suitable container.
- On models equipped with automatic transmission,disconnect A/T fluid lines.
- On all models, loosen cooling fan/clutch nuts, then disconnect radiator inlet hose from radiator.
- Remove power steering oil tank b...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1999 Suzuki Vitara AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1999 Suzuki Vitara 2.0 L4 GAS
- Disconnect battery ground cable at battery.
- Use a wrench to turn tensioner bolt clockwise, compressing te...
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1999 Suzuki Vitara AUTOMOBILES
Component location diagrams for most 1999 Suzuki Vitara cars and light trucks sold in the U.S. from 1990+.
 Engine Compartment Component Locations Diagram for 1999 Suzuki Vitara 1.6 L4 GASComponents on diagram: |
 Passenger Compartment Component Locations Diagram for 1999 Suzuki Vitara 1.6 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1999 Suzuki Vitara AUTOMOBILES
OEM drawn wiring diagrams for most 1999 Suzuki Vitara cars and light trucks sold in the U.S.
 1999 Suzuki Vitara 2.0 L4 GAS Wiring DiagramComponents on diagram: |
 1999 Suzuki Vitara 1.6 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1999 Suzuki Vitara AUTOMOBILES
OEM TSB listings for most 1999 Suzuki Vitara cars and light trucks sold in the U.S. from 1985+.
|
Document: SPECIAL COVERAGE ADJUSTMENT "PQ": CORROSION INSPECTION OF FRONT SUSPENSION FRAME Vehicle: 1999 Suzuki Vitara 1.6 L4 GAS Auto Systems: |
|
Document: OIL LEAK IDENTIFICATION Vehicle: 1999 Suzuki Vitara 1.6 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1999 Suzuki Vitara AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1999 Suzuki Vitara cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1999 Suzuki Vitara cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1999 Suzuki Vitara cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1999 Suzuki Vitara cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1999 Suzuki Vitara SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
