Auto Parts Search
2000 Dodge Caravan CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Component Replacement & Adjustment -> Light Trucks & Vans -> Accumulator, Replace -> Cherokee & Wrangler -> Dakota -> Full Size Pickups & Grand Cherokee
Vehicle: 2000 Dodge Caravan 3.3 V6 FLEX
Cherokee & Wrangler
- Recover refrigerant as outlined under .
- Disconnect wiring harness at low pressure cycling clutch switch and loosen screw at accumulator retaining band.
- Disconnect suction line from accumulator, then accumulator inlet tube from evaporator. Install plugs or tape over all open refrigerant lines.
- Remove accumulator from retaining band.
- Reverse procedure to install.
Full Size Pickups & Grand Cherokee
- Recover refrigerant as outlined under , then disconnect refrigerant lines from accumulator. Install a plug or ...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Disc Brakes -> Caravan, Town & Country & Voyager -> Precautions -> Bleeding Brakes -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General Precautions
Vehicle: 2000 Dodge Caravan 3.3 V6 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings. The wheel bearings should be inspected at this time and repacked if necessary.
Do not get any oil or grease on the linings. It is recommended that both front wheel sets be replaced whenever a respective pad is worn or damaged. Inspect and, if necessary, replace rear brake linings also.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness o...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
DaimlerChrysler Corp./Jeep Light Trucks, SUVs & Vans -> Fuel Filter Scheduled Maintenance -> Caravan, Town & Country & 1984-03 Voyager -> Normal Service -> Severe Service
Vehicle: 2000 Dodge Caravan 3.3 V6 GAS
Normal Servi...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
CV AXLE SHAFT, Replace -> Install -> Remove
Vehicle: 2000 Dodge Caravan 3.0 V6 GAS
Remove
- Remove cotter pin, nut lock, and spring washer from end of outer CV joint stub axle.
- Loosen (but do not remove) stub axle to hub/bearing retaining nut. Loosen hub nut while vehicle is on the floor with brakes applied. Front hub and driveshaft are splined together and retained by hub nut.
- Raise vehicle on jack stands or centered on a frame contact type hoist.
- Remove front tire and wheel assembly from hub.
- Remove front disc brake caliper assembly to steering knuckle guide pin attaching bolts.
- Remove disc brake caliper assembly from steering knuckle. Caliper is removed by f...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Starter, Replace
Vehicle: 2000 Dodge Caravan 3.0 V6 GAS
- Remove battery ground cable.
- Raise and support vehicle.
- Remove nut and lockwasher securing starter motor to mounting stud on manual transmission clutch housing or automatic transmission torque converter housing.
- While supporting starter with one hand, remove upper mounting screw from starter.
- On models equipped with automatic transmission,slide transmission cooler tube bracket forward on tubes far enough for starter motor flange to be removed from lower mounting stud.
- On all models, move starter motor towards front of vehicle...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2000-07 Caravan, Grand Caravan, Grand Voyager, Town & Country, Voyager & 2004-08 Pacifica
Vehicle: 2000 Dodge Caravan 2.4 L4 GAS
On 2000-03 models, the cabin air filter should be replaced every 15,000 miles.
On 2004-08 models, the cabin air filter should be replaced every 12,000 miles.
- The cabin air filter is located under the passenger side of the instrument panel behind a cabin air filter access door on the lower evaporator housing.
- Slide the cabin air filter access door latch rearward until the latch engages the open stop, Fig. .
- Remove the cabin air filter acc...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Chrysler LLC Trucks -> Electronic Throttle Control Indicator ->
Vehicle: 2000 Dodge Caravan 3.3 V6 FLEX
When the ignition is turned On, the lamp will light for approximately 6-12 seconds as a bulb inspection. If the lamp is illuminated with the engine running, the vehicle is usually drivable but the electronic throttle system must be diagnosed and servic...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Radiator, Replace
Vehicle: 2000 Dodge Caravan 2.4 L4 GAS
- Drain cooling system into a suitable container.
- Remove air inlet resonator.
- Remove coolant system to reserve tank hose.
- Disconnect fans electrical connector.
- Remove coolant recovery system tank retaining screw from upper radiator crossmember.
- Disconnect upper radiator mounting screws from crossmember, then disconnect engine block heater wire if equipped.
- Remove upp...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 Dodge Caravan AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2000 Dodge Caravan 3.3 V6 FLEX
- Raise vehicle and support vehicle.
- Remove right front splash ...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 Dodge Caravan AUTOMOBILES
Component location diagrams for most 2000 Dodge Caravan cars and light trucks sold in the U.S. from 1990+.
Engine Component Locations Diagram for 2000 Dodge Caravan 3.3 V6 GAS Components on diagram: |
Body Splice Locations Diagram for 2000 Dodge Caravan 3.3 V6 FLEX Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 Dodge Caravan AUTOMOBILES
OEM drawn wiring diagrams for most 2000 Dodge Caravan cars and light trucks sold in the U.S.
2000 Dodge Caravan 2.4 L4 GAS Wiring Diagram Components on diagram: |
2000 Dodge Caravan 2.4 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 Dodge Caravan AUTOMOBILES
OEM TSB listings for most 2000 Dodge Caravan cars and light trucks sold in the U.S. from 1985+.
Document: CHILD SEAT TETHER ANCHOR INSTALLATION - REV Vehicle: 2000 Dodge Caravan 3.0 V6 GAS Auto Systems: |
Document: AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE - REVISED Vehicle: 2000 Dodge Caravan 3.0 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 Dodge Caravan AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 Dodge Caravan cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 Dodge Caravan cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 Dodge Caravan cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 Dodge Caravan cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Caravan SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2000 Dodge Caravan vehicle. |
Access the Complete guide! |