Auto Parts Search
2000 Dodge Grand Caravan CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Computer Relearn Procedures -> DaimlerChrysler -> 1999-2002 Dakota, Durango, Ram Pick-Up & Ram Van -> 1999-2004 -> Controller Anti-Lock Brakes (CAB) -> Engine Performance -> Except 1999-2002 -> Light Truck & Vans -> Pinion Factor Procedure -> Powertrain Control Module (PCM) -> Sentry Key Immobilizer System (SKIS) -> Shift Quality -> Theft Alarm -> Transaxle Quick Learn Procedure
Vehicle: 2000 Dodge Grand Caravan 3.3 V6 GAS
Powertrain Control Module (PCM)
Except 1999-2002
If battery cable has been disconnected, the PCM must relearn a new operating strategy. Connect battery cable and run engine until operating temperature is reached. After engine warm-up, drive vehicle under various operating conditions until PCM has relearned new strategy.
1999-2004
Anytime the PCM is replaced the VIN and vehicle mileage must be programmed into the new PCM. If the PCM is not programmed, Diagnostic Trouble Codes (DTCs) will set. To program the PCM, connect a DRB or suitably programmed ...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Hydraulic Brake Systems -> Adjustments -> 1997-2000 -> 2001 -> Height Sensing Proportioning Valve -> Park Brake Cable Tensioner -> Stop Lamp Switch
Vehicle: 2000 Dodge Grand Caravan 3.8 V6 GAS
Height Sensing Proportioning Valve
1997-2000
- Raise and support vehicle, allowing rear suspension to hang free.
- Remove rear wheel and tire assemblies.
- Using an appropriate jack, support rear axle.
- Disconnect track bar from rear axle, then the shock absorbers.
- Loosen, but do not remove, both leaf spring to front spring hanger pivot bolts.
- Loosen adjustment nut on actuator, Fig. .
- Ensure hooked end of actuator is properly seated in clip on valve lever and clip is properly positioned on lever of valve.
- Pull housing of valve actuator toward spring hanger until lever on valve bottoms on body of va...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
DaimlerChrysler Corp./Jeep Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Rampage, Scamp, 1984-2000 Caravan, Town & Country & Voyager
Vehicle: 2000 Dodge Grand Caravan 3.3 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
On models equipped with fuel injected engines, r...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2000 Dodge Grand Caravan 3.0 V6 GAS
Front
- Remove cotter pin, nut lock, and spring washer from end of outer CV joint stub axle.
- Loosen (but do not remove) stub axle to hub/bearing retaining nut. Loosen hub nut while vehicle is on the floor with brakes applied. Front hub and driveshaft are splined together and retained by hub nut.
- Raise vehicle on jack stands or centered on a frame contact type hoist.
- Remove front tire and wheel assembly from hub.
- Remove front disc brake caliper assembly to steering knuckle guide pin attaching bolts.
- Remove disc brake caliper assembly from steering knuckle. Caliper is removed by fi...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Starter, Replace
Vehicle: 2000 Dodge Grand Caravan 3.3 V6 GAS
- Remove battery ground cable.
- Raise and support vehicle.
- Pull back protective rubber boot from solenoid battery terminal far enough to access and remove nut from positive cable harness connector eyelet.
- Remove nut that secures positive cable to solenoid terminal, then remove positive cable.
- Remove solenoid wire connecting ...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2000-07 Caravan, Grand Caravan, Grand Voyager, Town & Country, Voyager & 2004-08 Pacifica
Vehicle: 2000 Dodge Grand Caravan 3.0 V6 GAS
On 2000-03 models, the cabin air filter should be replaced every 15,000 miles.
On 2004-08 models, the cabin air filter should be replaced every 12,000 miles.
- The cabin air filter is located under the passenger side of the instrument panel behind a cabin air filter access door on the lower evaporator housing.
- Slide the cabin air filter access door latch rearward until the latch engages the open stop, Fig. .
- Remove the cabin air filter acc...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Chrysler LLC Trucks -> Electronic Throttle Control Indicator ->
Vehicle: 2000 Dodge Grand Caravan 3.8 V6 GAS
When the ignition is turned On, the lamp will light for approximately 6-12 seconds as a bulb inspection. If the lamp is illuminated with the engine running, the vehicle is usually drivable but the electronic throttle system must be diagnosed and servic...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Radiator, Replace
Vehicle: 2000 Dodge Grand Caravan 3.3 V6 FLEX
- Drain cooling system into suitable container.
- Remove hose clamps and hoses from radiator, then remove coolant reserve tank tube.
- Remove and plug automatic transmission hoses and auxiliary oil cooler, if equipped.
- Disconnect fan motor electrical connector, then remove fan and support assembly.
- Remove upper shroud fasteners, then lift shroud up...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 Dodge Grand Caravan AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2000 Dodge Grand Caravan 3.3 V6 GAS
- Raise vehicle and support vehicle.
- Rotate or lift the belt tensioner arm, using a suitable tool to reliev...
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 Dodge Grand Caravan AUTOMOBILES
Component location diagrams for most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S. from 1990+.
Underbody Connector Locations Diagram for 2000 Dodge Grand Caravan 3.3 V6 GAS Components on diagram: |
Engine Connector Locations Diagram for 2000 Dodge Grand Caravan 3.8 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 Dodge Grand Caravan AUTOMOBILES
OEM drawn wiring diagrams for most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S.
2000 Dodge Grand Caravan 3.8 V6 GAS Wiring Diagram Components on diagram: |
2000 Dodge Grand Caravan 3.8 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 Dodge Grand Caravan AUTOMOBILES
OEM TSB listings for most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S. from 1985+.
Document: CHILD SEAT TETHER ANCHOR INSTALLATION - REV Vehicle: 2000 Dodge Grand Caravan 3.0 V6 GAS Auto Systems: |
Document: AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE - REVISED Vehicle: 2000 Dodge Grand Caravan 3.0 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 Dodge Grand Caravan AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 Dodge Grand Caravan cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 Dodge Grand Caravan SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2000 Dodge Grand Caravan vehicle. |
Access the Complete guide! |